41 problems related to engine and engine cooling have been reported for the 2006 Ford Expedition. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2006 Ford Expedition based on all problems reported for the 2006 Expedition.
I have a 2006 Ford Expedition with 50,000 miles on it. My wife drives this car with our children. About 7 or 8 times now the check engine or (wrench light) comes on going down the road and shuts the car off completely. I have looked online and have seen that thousands of people are having the same thing happen to them. From what I read it has something to do with the electronic throttle control. I know you probably get complaints all the time but this is very serious. Every post on the web says that Ford has no recall and that the dealerships are doing nothing to fix this problem but putting a new part on and charging for it. This is absolutely ridiculous. There is obviously a problem. Please help me and others to fix this problem before someone gets hurt.
My 2006 Expedition had a spark plug blowout. I understand this is a frequent problem and is a design defect versus a maintenance issue. I did buy the extended warranty and have been told it is not covered.
My truck went into fail safe mode while on the highway. This caused the truck to stop suddenly with no use of gas pedal but the engine was still running. This almost caused an accident. I was able to drift over and shut the engine off and restart it and it ran fine the rest of the day. Now I am afraid to drive it.
My truck went into fail safe mode while on the highway. This causes the truck to stop suddenly with no power to accelerate but the engine still runs. This caused me to almost be crushed by a tractor trailer behind me. I had several children in the car too!!.
2006 Ford Expedition that cuts out while driving, started at approx 18k and has been to same Ford dealer 5 times. Problem has not recurred since last visit to dealer but could come back and is serious safety factor as a total loss of power without warning. Last repair noted a adjustment or repair to throttlebody.
2006 Ford Expedition has safety issues with engine. Consumer states that the engine gags or shakes upon ignition. Consumer is mostly worried about the wobbling when making turns. Claims there is loss of power. The rear latch would stick at times to the point where the door would not close.