39 problems related to engine failure have been reported for the 2006 Ford Expedition. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2006 Ford Expedition based on all problems reported for the 2006 Expedition.
Relating to article. . Read more...
Engine shuts off while driving down the street. Engine fail-safe light is displayed. Was barely able to steer the vehicle to a safe area. Restarted engine, everything came back up again.
1/8/09 while driving at 65 mph on highway vehicle's "engine fail safe mode" alarm sounded & message flashed on panel. Vehicle immediately lost power. I was able to coast to shoulder of road. Turned off vehicle, restarted and was able to drive approximately 1 1/2 miles. I was in turn lane, started to turn left, alarm sounded, message flashed and all power was gone. I quickly turned vehicle off and back on to try and get out of path of oncoming tractor trailer. I was able to get just off roadway after 15 mins started vehicle, drove 4 miles failed again. It was towed to mechanic. After calls to Ford and further testing the electronic throttle body assembly was replaced. On 1/30/10, 35 miles from home, driving on highway at 55 mph when "engine fail safe mode" alarm sounded & message flashed on panel. Again I was able to safely pull to shoulder of road to avoid accident. I called Ford dealer located in that town, had vehicle again towed to shop and they replaced an additional part. I called Ford after 2nd event, I was told by Ford that they are aware of the problem, however since they don't have a solution to it they do not have a recall on this. On 4/20/11 while driving home from work on highway at 60 mph the "engine fail safe mode" alarm & message flashing on panel. I was in far right lane so again was able to coast to shoulder before steering locked from no power. If I had been in left lane I would not have been able to get off roadway. (on 4/19/11 I had vehicle inspected, in nys, no codes were on this vehicle). Towed to shop, after running tests and calls to Ford they have again replaced the electronic throttle body assembly as it had failed. Still no recall. This is extreme safety issue. I have avoided accidents 3 times, if I had been in left lanes I would not have been so lucky. This happens with no advance warning. Ford knows there is a problem.
My 2006 Ford Expedition suddenly shuts down for the third time now while driving on the road. The engine shuts down suddenly and gives out the engine fail safe mode message on the board. Dealer says nothing showing up on the diagnostics. How could that be. There's got to be a reason why that SUV suddenly shut its engine down. Accident will happen if this will not be resolved.