17 problems related to brake disc have been reported for the 1999 Ford F-250. The most recently reported issues are listed below.
On 7/12/2000 I took the truck to the dealer because of severe vibration when braking from highway speed. At that time the dealer turned the rotors because they were warped. Now 6 months later the problem has re-occurred. Given the information I have found on the internet regarding simular problems from other owners, it can only be concluded that this is a design defect. However, at this time, both the manufacturer and dealer refuse to adequately address the problem.
No summary listed for abov evehicle.
Dealer replaced warped rotors, calipers and pads to eliminate pulsating. Pulsation is beginning to recur.
At about every 7000 mile increments my brakes begin to exhibit "brake shudder" a vibration that occurs when the brakes are applied. Not until I was able to obtain a technical service bulliten and show my Ford dealer was I able to get the problem resolved. Followng is the technical service bulletin: some 1999-2000 super duty f-series and 2000 excursions may exhibit brake vibration or shudder while braking. Engineering has released a new brake pad (p/n f81z-2001-ea), which is equipped with a "v-spring. " the v-spring keeps the brake pad off the rotor, which increases brake pad life and decreases brake shudder and noise. When replacing these brake pad use the pro-cut brake lathe to machine the rotors on the vehicle to a lateral run-out of . 001" or less. Besides the shudder the thing that concerns me the most is the vehicle starts to pull to left or right when I apply the brakes. Thank you for you consideration on this issue. L.
6 alignments in 24,000 miles, a broken 14mm suspension bolt, a steering gearbox failure, 3 sets of brakes & rotor/caliper replacement indicates major design/material & quality problems. The vehicle has also left me stranded 5 times for other not listed engine related failures. Ford customer relations is useless, could care less & is non-supportive.
Every 5000 miles vehicle starts to vibrate in front when driving. Dealer had to replace warped front rotors/calipers and pads. This has been done 3 times.
After brake work was preformed on vehicle. When hauling and upon braking vehicle will vibrate. Consumer has not contacted dealer. Please provide any further details.
The front end of the vehicle begins to shudder when braking at freeway speeds (60-65mph and sometimes less). In January of '99 the front rotors had to be turned to correct the problem temporarily. The problem returned again and the rotors had to be turned a second time in October of '99. The truck only has about 17k miles. The shuddering has the potential of causing an accident or pemature failure of not only the brake parts but also the front end components.
When applying the brakes at speeds 45 mph / above normal, the front end of the vehicle severely vibrates. Ford is aware of the problem, but does not know how to correct it. . Et.
Rotors have been recut 3 times. Brake pads have not needed replacement yet. When I jamed on brakes they vibrated then faded causing a rear end collision.
Every 3,000 miles brakes will pulsate due to warping of the rotors, causing wear on brake pads and shoes.
Brake pads are disintegrating on all four wheels. Also, rotors are scored. Contacted dealer, and dealer pads had to be repaired.
Brakes comepletely release when applied and hitting bump in road,must depress pedal to the floor to stop,on several occaisions. I've had three near accidents in past 30 days.
Under warranty rotors machined and brake pads replaced. Second time, rotors machined and new Ford part number for pads replaced. Brake failure possibly responsible for accident with injury.
When applying the brakes vehicle severely pulls to the left, cause unknown. Please give any further details.
Disc brakes fill up with mud , tearing rear brakes and rotors and causing loss of brakes.
Front brakes are terrible. Vibration, upon braking, loud noise when truck first strarts.