Power Train Driveline Problems of Ford F-550

04 Ford f550 sd dump truck was bought new on 12/04. . In April 2005 transmission leaked fluid while in park and truck was towed to dealer. The dealer claimed cause of problem was due to loose bolts on trans case. Transmission continued to slip but dealer could not find problem. February 2006, approximately 16,000 miles on truck, transmission completely fails. Truck towed to dealership and new transmission installed. On June 2008 (approximately 56,000 miles) while driving on major highway, truck begins to lose power and black smoke pours out of muffler. The truck was driven to local dealership and diagnosed with a blown turbo. Ford did not cover cost of repair. I paid $4,500. 00 out of pocket to replace turbo. August 2009 (approximately 68,000 miles) again while driving on major highway, truck loses power and stalls. Truck was towed to Ford dealership and diagnosed with clogged injectors due to deteriorating gas tank. Dealer advised me that all 8 injectors would have to be replaced and new fuel pump installed. The total cost of repairs would be $4,300. 00 and it would not be covered by Ford. I was incensed to say the least. . . After getting a second opinion, I paid an additional $475. 00 and had the truck towed to another Ford dealership which made the repairs without any cost to me. The fuel tank was not replaced even though it was the cause of the problem. I replaced the tank and paid $750. 00 out of pocket. . . December 27, 2010 (96,000 miles) without warning, transmission begins to slip. I contacted the Ford dealership that made the last repairs. I was told the transmission was out of warranty and would not be covered by Ford. It would cost $4,200. 00 to replace. I took truck to a local transmission repair shop and paid $3,000. 00 to rebuild transmission. Its obvious that Ford does not back up their product. I will never buy another Ford again!!!!.

See all problems of the 2004 Ford F-550 🔎.

On 2005 Ford F-550, the rear axle seal in passenger side leaks. Brakes are coated with gear oil when his occurs. Ford TSB # 05124 has been done but does not work. My vehicle has had four repairs ( 3 seal replacements and 1 attempt as per TSB ) and all have failed. Truck has @ 24,000 miles on it.

See all problems of the 2005 Ford F-550 🔎.

Bolts that attach the yoke to the transmission came loose, causing the driveshaft to drop. Driveshaft dug into the pavement, causing driver to lose control of the vehicle. Truck was towed to the dealership. Truck, which is owned by smoth towing is being is being repaired. Truck is owned by . Please provide any further information.

See all problems of the 2000 Ford F-550 🔎.