Fuel Hoses Lines/piping And Fittings Problems of Ford Mustang

The contact owns 2006 Ford Mustang. The contact stated while adding fuel to the vehicle it continued to spill out of the fuel tank on the contact and on the ground. The contact took the vehicle to the dealer regarding the failure and the dealer found a restriction blocking the fuel tank vent line. The vehicle was repaired when the dealer cleared the vent line. The contact stated the fuel spill could have caused a fire. The failure mileage was 23,450.

See all problems of the 2006 Ford Mustang 🔎.

The contact owns a 2010 Ford Mustang. While rotating the tires, he noticed the fuel line was had fractured and was dangling from its housing. The vehicle was taken to the dealer however; the bracket for the fuel line was missing. The dealer advised that the bracket was not a part that was sold individually and the entire fuel line assembly cover would need to be purchased and replaced. The vehicle was not repaired. The failure and current mileages were 3,733. The consumer stated the problem he is having is not only specific to his vehicle. He found two other models that had the same missing fuel line support bracket; a 2010 v6 model and a 2011 v8 gt model. Updated 07/13/10.

See all problems of the 2010 Ford Mustang 🔎.

When I filled my car with gas it started to overflow out of the top through the gas cap area and pour out of the bottom. I had my father check it about an hour later while it was parked and he couldn't find a leak. We determined the automatic stop on the pump must have failed. I went to put $20 of gas in it two days ago and once again it was pouring out of the bottom. Since I didn't fill it up this time, I knew it had to be my car and not the pump. I had my mechanic look at it and he determined the fuel filler hose has rusted through all the way to the plastic cover around it. He told me my car is safe to be driven but not to put gas in. I've ordered the $184 part to repair it and am currently waiting for it to come in to the dealer. I found many complaints of this incident but no official recalls by Ford. Did I miss something somewhere? it seems to me if there are that many problems with this particular part of the car, Ford would have done a recall.

See all problems of the 2001 Ford Mustang 🔎.

Fuel tank and inlet tube fails to fill properly. Gasoline splash back on to motorist at filling station. Tried to put convertible top down, catastrophic failure of convertible top frame and hardware. No forewarning.

See all problems of the 2005 Ford Mustang 🔎.

The gas tank is very hard to fill if the tank is over 1/4 tank. It doesn't matter what gas station you use or how the handle is positioned. The automatic fuel shutoff feature of the gas handle will shut off as if there were back pressure.

Potential fire hazard. Can not fuel vehicle. After approximately 1/2 tank, gas station fuel nozzle shut off. Tried slightly engaging nozzle, and continued to shut off. After multiple tries and multiple gas stations, could fill tank to 3/4 tank, then shut off recurred. Will no longer accept fuel. Fuel spillage occurred on almost all shut off incidents, no matter what pressure fuel was transferred at (by regulating handle). After research on internet, found many other owners complaining of same issue (see allfordmustang. Com's 2005+ forums) with some having resolve after tank and / or filler tube /vent replacement. Tried their suggestion of placing nozzle in different directions did not help. Also reference Ford service bulletin 06313 (NHTSA item number 10019387) taking to dealership tomorrow. Not the first occurrence on this vehicle. Has shut off before prematurely, but has always restarted with no spillage / recurring. Vehicle only has 1200 miles on it.

The fuel tank is very difficult to get fuel in when the tank is over 1/4 full. This has been going on since I bought the car and Ford recognizes the problem but doesn't have a fix. I have been told to try other gas stations. It doesn't matter which gas station or how the hose is positioned.

Problems with gas leaking from vehicle. Everytime the gas tank was filled 1/2 to full, gas leaked at the connector where the intake pipe meets the tank. The rubber seal at the connector was very loose and wet when gas leaked. There was a smell of gas.

See all problems of the 1998 Ford Mustang 🔎.

The rubber seal between the fuel filler pipe and the fuel tank split causing fuel to leak out onto the ground. This could cause a fire or an environmental spill.

See all problems of the 1997 Ford Mustang 🔎.

While driving, noticed and smelled smoke; checked underhood, vehicle wasengulfed with flames, no warning, dealer determined fire caused by defective fuel line.

See all problems of the 1996 Ford Mustang 🔎.

While driving up hill between 30-45 mph vehicle bottomed out. Cause of problem fuel relay cut off switch failed. Owner had no control vehicle when problem occurred. Manufacturer has not been notified.

My husband I purchased a 1998 rouch Mustang gt. The conversion kit includes side pipes, computer chip, different suspension, and some things im not sure of. I have been having problems with raw fuel smell coming into cab of car. It get's very bad. It only happens when it is 85 degrees or above. And only happens randemly. One day while driving my daughter from school, fuel smell came into cab. Daughter and I gaged. Pulled over and shut car off. Took car to dealer, they said they were waiting for new fuel line from the roush company. I was told that the rouch cars needed different fuel line then that of the manufacturer. They said they fixed the problem. Then my husband and I were going to daytona. It happened again. Pulled into dealership shut car off with windows down. Ten to fifteen minutes gone by before george nagel the service manager sat in it. He kept car do to he smell of fuel. And that is after the car sitting there airing out. He smelled it coming from the vents. They said they fixed it . Happened again. Now goerge is saying that he does not know if it was gas or emmisions that he smelled. My car know sits in my driveway, I am renting a car. I am doing lemon law. I was told by an attorney if I can not prove my case they will lean towards the manufacure. There is a serious problem with my car. I am afraid of this car. I have owned Mustangs for many years now. Thats all I have owned. I love my car. I'm afraid to drive it. But my safety is at risk. Please help me.