Engine Failure problems of the 2011 Hyundai Sonata

2011 Hyundai Sonata. Consumer writes in regards to NHTSA safety recall 15v-568. The consumer requested to be included in the recall, as the vehicle has experienced the same failure. There was metallic debris in the engine crankshaft. This caused the rod bearings to be restricted of oil flow and caused my rod bearings to be damaged. The engine failed.

The contact owns a 2011 Hyundai Sonata. The contact stated that while approaching a stop light at 5 mph, the vehicle shut-off with several unknown warning lights illuminated. Due to the failure, the contact had the vehicle towed to an independent mechanic where the vehicle was diagnosed with engine failure. The contact went to kendall Hyundai (15895 s dixie hwy, miami, FL 33157) and was informed to tow the vehicle in to be diagnosed. Upon investigation, the contact linked the failure to NHTSA campaign number: 15v568000 (engine) however, the VIN was not included. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was unknown.

My engine failed while driving. . . . . I had it towed to Hyundai dealer because I was informef about vehicle recall. The dealership will not provide me with loaner car without full coverage insurance. I have been without my vehicle almost 30 days.

Engine failed / blew while driving.

The contact owns a 2011 Hyundai Sonata. The contact stated that her son was driving at 70 mph and the engine ceased. The contact's son guided the vehicle from the middle lane to the side of the highway. The vehicle would not restart. The vehicle was towed first to an independnent mechanic and he diagnosed the vehicle with engine failure. The vehicle was then towed to the dealer Hyundai of central florida (17325 e highway 50 clermont, FL 34711, 888-566-5820) who confirmed the same diagnosis of the engine ceasing. The contact was not given the specific reason as to why the engine ceased. The dealer initially stated that there was a recall on the engine and would submit a request to the manufacturer. The contact called and confirmed with the manufacturer the engine was covered under a recall and would contact the dealer to repair the vehicle. The manufacturer then declined the repair by email stating that the vehicle was four years out of warranty. The vehicle was not repaired. The failure mileage was 53,000.

Vehicle stalled on highway would not start had to be towed on 10/1/19. Towed to service vendor, not a Hyundai dealer. They stated engine locked. Vehicle had been at st charles Hyundai automotive 8/19/19 replaced oil flow control valve. Contacted Hyundai dealer stated nothing they could do. Mileage 138,000 and all required service had been done. Recall 132 inspection had been done at approximately 58,000 on 2/15/16. Noted number of complaints to NHTSA showing numerous 2011 Sonata had engine failure after the extended format of 120,000 and many had failed a second time after engines failed. This vehicle was built at alabama plant. The Hyundai dealership stated the vehicle would have to be towed to their facility and inspected. The decision would be Hyundai USA not the dealership. It is hard to understand how this can not be a defective vehicle. The number of units repaired and repaired a second time goes against the averages . The number of fires that have resulted in total loss of vehicles appears to be and indication of numerous issues with vehicles from this plant. It will cost $4500 to replace this engine and Hyundai USA should bear some of the cost. If after engine replacement vehicle performed properly that would prove the correction, but many units had to have the neck filler replaced the plant had a problem. Engines failed with only 10,000, 30,000 65,000, 135,000 miles. The units that burnt were handled by insurance and Hyundai USA not held accountable. Please reopen the investigation on recall 132 the number of owners are bearing the brunt of Hyundai poor quality. Understanding they completely changed that engine in 2012 knowing the 2011 issues could not be fixed correctly.

Engine failure.

Reference VIN# 5npe c4ac 5bh1 7045 4 2011 Hyundai Sonata 129,044 miles at engine failure on March 19, 2019 Hyundai case# 15847818, campaign 132, total engine failure, claim is in the sum of $5054. 95, complaint: all requested documentation for invoices, owner registration, and associated information has been submitted to the Hyundai client care specialist in a timely manner. Hyundai campaign 132 document rcmn-15v568-2234 directs that required vehicle inspection will be done at no cost to claimant. Hyundai client care specialist, refuses to contact the Hyundai dealer to authorize vehicle inspection at no cost to claimant per referenced Hyundai procedure. Local Hyundai dealer in savannah, georgia, refuses to contact Hyundai for authorization to perform the required vehicle inspection at no cost to claimant. Dealer advises that we make a claim for this expense to Hyundai. At this point, August 19, 2019, Hyundai has made no indication that they will actually honor any claim for expenses.

Tl the contact owns a 2011 Hyundai Sonata. While driving 75 mph, the engine failed and the vehicle stalled without warning. The vehicle was towed to duncan Hyundai (2050 roanoke street, christiansburg, virginia 24073, (540) 382-2100) where it was diagnosed that the motor failed. The manufacturer was made aware of the failure and provided case number: 114-85-200. The failure mileage was approximately 79,000.

Tl the contact owns a 2011 Hyundai Sonata. While driving approximately 35 mph, the vehicle stalled without warning. The vehicle failed to restart and all the warning indicators illuminated. In order to move the vehicle out of traffic, a police officer had to physically push the vehicle over to the road shoulder. The vehicle was towed to an independent mechanic where it was diagnosed that the engine failed and needed to be replaced. The vehicle was not repaired due to the repair fees. The vehicle was not taken to a dealer. The manufacturer was not contacted. The approximate failure mileage was 130,000.

Tl the contact owns a 2011 Hyundai Sonata. The contact stated that there was engine failure. The dealer (thompson Hyundai, 1000 merritt blvd, baltimore, MD 21222, (410) 288-5700) serviced the vehicle for four recalls, of which one that pertained to the engine assembly. However, the failure continued and the service engine warning indicator remained illuminated. The vehicle was taken to more than one independent mechanic for diagnostic testing. The manufacturer issued ten tsbs for the engine and engine cooling and one recall for the engine assembly, but the vehicle was not included in a recall. The manufacturer was notified of the failures. The approximate failure mileage was 92,633.

Engine failure while driving in middle of road without any warning. When attempting to restart vehicle smoked and smelled of electrical burning. Hyundai service center originally said this vehicle was not part of the 2011 Hyundai Sonata theta ii engine recall, but when advising I found online (specifically at autoservice. Hyundaiusa. Com) that it indeed was, they agreed to check vehicle and contact Hyundai to have added to the recall. This vehicle exhibits all the problems mentioned in the recall/lawsuit. They occurred suddenly and without notice. We were at risk of crashing or being hit by a vehicle due to manner in which it broke down. Vehicle was at risk of fire, as it smelled of burning and smoked. Vehicle was left at service center and am awaiting response.

The contact owns a 2011 Hyundai Sonata. While driving 40 mph, the vehicle stalled without warning. The vehicle was towed to del ray Hyundai, Acura of del ray beach, florida (located at 655 ne 6th Ave, 33483) where the engine assembly was replaced. The contact stated that the engine indicator illuminated directly after the repair was completed. The vehicle was taken back to the same dealer on three occasions where the fuel cap and canister close valve were replaced, but the engine failure warning indicator kept illuminating. In addition, the contact stated that the engine indicator illuminated intermittently at first, and then on a constant basis. The manufacturer was not made aware of the issue. The failure mileage was approximately 92,000.

The contact owns a 2011 Hyundai Sonata. The contact received a recall notification for NHTSA campaign number: 15v568000 (engine) to have the engine replaced. The vehicle was repaired with a brand new engine in April of 2016, but the engine failed again on may 9, 2016. The manufacturer declined to repair the vehicle. The vehicle was not repaired. The approximate failure mileage was 128,000.

My car just stalled on me yesterday April 6th, 2017 when I was driving to a friends house, on the street in motion. I was in mid-drive and it just stalled, all the dash lights went on and I couldn't accelerate anymore. I had to coast all the way to a gas station, barely making it. Turned the key to the off position and back on and it just turned on again. Took it to harbor Hyundai this morning and they first said there was nothing wrong with it, then they told be the oil light went on and it could be engine failure and I should sell my car for parts or drive it until it fails. And what a coincidence that this morning a recall on 2013 - 2014 Hyundais with engine stalling. So Hyundai isn't doing anything for me. I need help, I think my car year should be included in this recap as well.

Tl the contact owns a 2011 Hyundai Sonata. The contact stated that the engine failed to function normally. The vehicle was taken to atlantic Hyundai (193 sunrise hwy north service rd, west islip, NY 11795, (631) 587-0700) where it was repaired per NHTSA campaign number: 18v934000 (engine, fuel system, gasoline). The remedy failed and the check engine indicator illuminated; however, the dealer refused to repair the vehicle again. In addition, the tail lights shorted out numerous times and the bulbs were replaced more than five times. The vehicle was unable to be driven due to the faulty engine. The manufacturer was notified of the failure and did not assist. The failure mileage was not available.

Car went in for engine test for the recall. Engine failed the test which should have meant that the engine needed to be replaced. After 90 days a Hyundai rep came to the dealership and determined that the engine did not need to be replaced. If the car fails the test how can they just deem that they don't need to fix it. Also can I request that they sign a letter of liable in the event of future engine issues, since they won't fix a government mandated recall, how will I ever get them to own up to any other issues that arise?.

The contact owns a 2011 Hyundai Sonata. The contact stated that the vehicle failed to start. The vehicle was taken to the dealer where it was diagnosed that the engine failed and needed to be repaired. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was 68,000.

No one can fix my recalls - im scared to drive this car I have a 2 year old need payoff amount to I can buy new car! NHTSA recall number: opens new window takes away from VIN lookup section> 15v568000 recall date: September 10, 2015 safety risk: engine failure would result in a vehicle stall, increasing the risk of a crash. . Read more...

On third engine that is finally recalled with campaign 132 but how do I know if the current engine is defective or not? took car to dealership and they said it 'passed' the one time recall check. This is a joke. First engine failed at 96k and second at 10 miles and now who knows when third will fail or not? can't get Hyundai customer care nor dealership to take the time to tell me when the current engine was made. Have 119k on car now. I am frustrated and can't get answers. . . Can you help me?.

The contact owns a 2011 Hyundai Sonata. The contact stated that the engine failed. While driving 50 mph, the lights on the instrument panel illuminated and smoke emitted under the hood. The contact was able to move onto the shoulder of the road. The vehicle was towed to a local mechanic who performed a diagnostic, which located a failure code at the engine starter. The vehicle was not repaired. The manufacturer was not notified. The VIN was not available. The failure mileage was 96,970.

While driving at 45-50 mph, on highway, experienced catastrophic engine failure and other significant component failures, resulting in a very dangerous situation for driver, passengers, surrounding traffic , noises, smoke caution lights loss of power and control. Immediate evasive action had to be taking to avoid injury or loss of life. Once at rest, vehicle continued to smoke immensely. Low mileage, very disturbing and concerned for others driving these ticking bombs! Hyundai needs to address this issue with more strength and direction.

Tl-the contact owns a 2011 Hyundai Sonata. The contact stated that while traveling at 35mph the engine seized without warning. The vehicle was towed to a dealer where it was diagnosed that the engine failed and needed to be replaced. The vehicle was not repaired. The contact received notification of NHTSA campaign numbers: 14v433000 (service brakes, hydraulic), 14v434000 (power train) and 15v568000 (engine). The contact stated that the dealer is refusing to do the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 70,000. Ec.

As I was driving the vehicle , I was experiencing loss of power and even engine failure. Re-started and continued to proceed. Traveling approximately 25 miles per hour down hill coasting, engine died for the third time in less than 4 blocks. Pulled over attempted to re-start again and heard a loud bang under the hood. Pull off to side of road , to view lose of oil and steam from engine. Open hood view smoke and plenty of oil sprayed out back of engine. No power or ability to move vehicle. Called tow truck and once received information from mechanic that rod went through engine block. I repaired the vehicle with $4800. 00 cost and a used 2013 engine. Come to find out, several hundred 2011 Hyundai Sonata engine are have same issue.

Tl-the contact owns a 2011 Hyundai Sonata. The contact stated that while driving at approximately 55 mph, the engine stalled without warning. The vehicle was towed to an independent mechanic where it was diagnosed that the engine failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure and the VIN was included in NHTSA campaign number: 15v56800 (engine) however, the part to do the repair was unavailable. The failure mileage was approximately 110,000. Sg.

I was on the freeway driving at 65 mph when the engine stalled and shut off. There were no warning lights indicating an issue with the engine. I was informed later by my mechanic that the engine had a catastrophic failure. The brakes failed because the engine was not running. I was lucky and able to coast to the next exit, the stop light was green and I could make it to safe location. Had the engine failed a few minutes earlier I would have been in the fast lane of the freeway trying to make it to the shoulder. Or trying to stop at a light with no brakes.

While driving home the car just stopped and shut off. Before shutting off it was like the car lost all power. What I mean is that the even though the gas pedal was pressed the car would not move. I had to leave my car on side of a very dark and dangerous road. The next day I went to retrieve my car. I saw oil spots on the ground where I had pulled off the road and under the hood. Again, my car would not start, so I had to tow it home. I called tuscaloosa Hyundai and they told me that since my car was past the mileage warranty that the cost would be on me and that I would need a new motor. I informed the mechanic about the complaints on the 2011 model and I was having the same issues before my car stopped. John told me that, I just cant believe everything that I read. I'm very unsatisfied with his comment. He told me that I would just need a new engine. I can not afford this. I know that I have taken care of my car and for Hyundai to sat this is my fault is garbage. They know that they have messed up and are refusing to fix this problem. There is a class action lawsuit against Hyundai for premature engine failure. I just dont know what else to do. I have been without my car for 6 months now and I haven't gotten any where. I still have a car note and insurance.

My 2011 Hyundai Sonata like many of the other complaints on here has had catastrophic engine failure due to a snapped rod. Like many of you I have kept up with the regular maintenance schedule and have been shut down by Hyundai for repair under the 100,000 mile warranty. This problem is a serious public safety concern as it happens while the car is in motion and my question is what will it take for the NHTSA to take action and fully investigate this issue and bring it to recall? with the amount of complaints listed on the NHTSA website for this exact issue it seems like they are waiting for injury or even worse to occur before this issue is taken seriously.

Engine seized and I had it replaced at a cost of$3,620. 04. As per the agreement they made regarding the engine failing due to metal objects being in the engine that was their fault, they would reimburse owners for this cost. I have been waiting over 6 months and when I called, they stalled by requesting me to prove I owned the vehicle by submitting my registration or insurance for the vehicle. I traded in the vehicle last fall and do not have the the items anymore . My name is on the bill I paid for the engine replacement, this is just another way they can try to not pay even they agreed to pay. The engine failed at the savannah airport.

My spouse was driving on interstate 280 southbound in the bay area during the morning commute when an engine rod came loose and punctured a whole in the engine causing catastrophic engine failure. The engine failure led to loss of power to the steering and brakes and the car coasted off the interstate exit ramp and eventually came to a stop after the emergency brake was engaged. The car has consistently received regular maintenance from the local authorized Hyundai dealer and car service provider. There was absolutely no warning before the engine flew apart. This was a very dangerous incident that could have led to the death of the driver, any passengers, and other drivers and passengers of nearby cars.

Tl-the contact owns a 2011 Hyundai Sonata. The contact stated that while driving at various speeds, the vehicle began to consume large amounts of oil. The vehicle was taken to a dealer where the failure was not determined. The vehicle was not repaired. The vehicle was taken to a different independent mechanic where it was diagnosed that the engine failed and needed to be replaced. The vehicle was repaired under NHTSA campaign:15v568000 (engine). The manufacturer was notified of the failure. The failure mileage was approximately 70,000. Ec.