Air Bag Problems of Hyundai Sonata - part 2

The contact owns a 2013 Hyundai Sonata. The contact stated that while driving approximately 35 mph, the front driver's side air bag unexpectedly deployed without an impact to the vehicle. The air bag warning light illuminated prior to the incident. The contact then crashed into the rear of a utility trailer where it came to a stop. The contact broke a tooth. The paramedics were called and performed a check; however, the contact did not go to the hospital or urgent car. A police report was filed. The vehicle was towed to a towing yard. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The insurance company was contacted and declared the vehicle a total loss. The manufacturer was made aware of the failure. The failure mileage was approximately 140,000.

See all problems of the 2013 Hyundai Sonata 🔎.

On [xxx], in washington, d. C. , my 2013 Hyundai Sonata experienced sudden engine failure, leaving the vehicle inoperable. My goodwill repair request was denied within 30 minutes, without a proper inspection of the rod bearings (a known failure point covered under the txxi extended warranty) or the fuel pipe recall—a known issue that could pose a fire hazard. Hyundai cited suspected maintenance neglect, but I have documentation of regular synthetic oil changes. Despite having over 200,000 miles, a firestone inspection from September 2024 confirmed the vehicle was in good condition prior to the failure. Additionally, Hyundai theta ii engines are widely known to suffer from excessive oil consumption, a defect that can lead to premature engine failure even in well-maintained vehicles. Hyundai has replaced engines in vehicles with similar mileage under the same extended warranty, yet in this case, no proper inspection was conducted before denial. Safety concerns: the fuel pipe recall was not inspected, raising concerns about whether unresolved recall defects are leading to engine failures or fire risks. The airbag clock spring, covered under Hyundai’s txxa extended warranty, was not inspected, despite the airbag light being illuminated, potentially affecting airbag deployment in a crash. The vehicle failed without warning lights or error messages, creating an unsafe situation. Hyundai’s failure to inspect recall-related issues before denying repairs could impact other affected vehicles on the road. I request that the NHTSA: ensure Hyundai properly inspects recall-related components before denying repairs. Investigate whether Hyundai is improperly denying warranty and recall-related repairs, even in cases where similar vehicles have received replacements. Determine if the unresolved fuel pipe recall and airbag clock spring defect pose broader safety risks. This issue has been reported to Hyundai corporate, but no proper inspection has been performed. Information redacted pursuant to the freedom of informatio.

The contact owned a 2009 Hyundai Sonata. The contact stated that while his daughter was driving at 45 mph, the vehicle was turning the corner. It was unknown if any warning lights were illuminated. As a result, the vehicle was t-boned by a vehicle that was turning the corner, then crashed and the vehicle came to a stop at an unknown location. Most of the impact was received from the front passenger side. The other divers speed was unknown. None of the air bags deployed. The contact suffered injuries to the head and the lungs when she impacted the steering wheel. The contact was taken to the hospital by an ambulance. The contact's daughter was in a coma and had brain trauma and a punctured lung. A police report was filed. The vehicle was towed to a tow yard. The other vehicle owner was injured as well, the extent of his injuries was unknown. There was no property damage. The manufacturer was not made aware of the failure. The failure mileage was 140,000.

See all problems of the 2009 Hyundai Sonata 🔎.

The contact owns a 2019 Hyundai Sonata. The contact stated that while her husband was driving at 15 mph in a residential area, another vehicle coming from the left side tried to pass the contact into oncoming traffic, as the contact's husband was trying to slow down to make a u-turn. As a result, the other driver's vehicle then crashed into the contact's husband. There were no warning lights illuminated. None of the air bags deployed. The vehicle was idled back to a friend's place of residence. The contact's husband suffered injuries from the vehicle collision. The contact's husband went to the hospital a day after the collision and was informed he would be sore for a couple of days. A police report was filed. The vehicle has not been repaired or taken to be diagnosed. The contact stated that she had notified the other vehicle's insurance and was awaiting a response. The dealer has not been made aware of the failure. The manufacturer was not made aware of the failure. The failure mileage was 100,000.

See all problems of the 2019 Hyundai Sonata 🔎.

Airbag light is on after a clock spring issue. Dealer is stating new airbag is needed for vehicle that has never had an accident. Airbag light was not on prior to clock spring malfunction. Clockspring was repaired, but airbag light remains on.

See all problems of the 2011 Hyundai Sonata 🔎.

Air bag warning has come on due to malfunctioning clockspring. Went to dealership and realized it is not under extended 15 year warranty. Even though, 2011-2013 Sonatas, elantras, and 2011-2014 hybrid Sonatas are covered. Being so close in years this is disappointing to learn that the warranty was cut off, although it obviously seems to be an ongoing problem.

See all problems of the 2014 Hyundai Sonata 🔎.

The contact's daughter owns a 2007 Hyundai Sonata. The contact stated that the air bag warning light was illuminated. The vehicle was taken to the dealer to be diagnosed. The dealer determined that the front passenger's side seat cushion assembly needed to be replaced due to the occupant classification system (OCS) failure. The dealer related the failure to NHTSA campaign number: 08v161000 (air bags). The dealer informed the contact that the vehicle could not be repaired because the part had been discontinued. The dealer referred the contact to the junkyard to purchase the parts. The manufacturer was notified of the failure and provided the same assessment. The vehicle was not repaired. The failure mileage was approximately 181,416.

See all problems of the 2007 Hyundai Sonata 🔎.

Dashboard has large cracks all over it including where the passenger air bag is located. I am concerned about the pieces of plastic flying if the air bag deploys. Also concerned that the cracks could release the air bag at any time, even during normal driving. Dealer only suggested getting a dashboard cover, but that would negate the purpose of the air bag. My research showed that there are many other cases of the happening with Hyundai Sonata's 2011-2014.

Srs light on. Problem code indicates high resistance on driver's side air bag. Dealer said it was the airbag control module, but refused to give me the actual estimate or anything in writing other than problem description. There was a recall for other 2013 Sonata airbag control modules, mine was not included apparently, but it has the same issue as the recalled ones. Dealer wants $3000 to replace the module.

Car is overheating. Took it to a mechanic they replaced the thermostat but car is still overheating, jerking and so much more. The mechanic wants to charge more to fix it. I got a second opinion from another mechanic and after he reviewed the paperwork from the first mechanic. He searched my VIN number and told me to contact this number because my vehicle is on a recall list. So I need someone to contact me about where and how we can get my vehicle fixed.

The contact owns a 2011 Hyundai Sonata. The contact stated while driving 20 mph, several unknown warning lights illuminated. The contact stated while attempting to make a right turn, the steering wheel seized, and the electrical system became inoperable. The vehicle was not diagnosed or repaired. The VIN was not included in NHTSA campaign number: 20v746000 (engine) nor 18v137000 (seat belts, air bags). The manufacturer was notified of the failure. The failure mileage was 100,000.

The contact owns a 2006 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, the air bag warning light illuminated. The vehicle was not taken to the dealer or an independent mechanic. After investigating the failure, the contact related the failure to NHTSA campaign number: 08v161000 (air bags); however, the VIN was not included. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 140,000.

See all problems of the 2006 Hyundai Sonata 🔎.

The contact owns a 2014 Hyundai Sonata. The contact stated that the driver’s air bag warning light was displayed on the instrument panel. The vehicle was taken to a dealer and the contact was provided an estimate for the repair. The service technician stated that there were no recalls on the VIN related to the failure. The failure persisted and the contact stated that the electrical functions on the steering failed to operate as needed. The manufacturer was notified of the failure and the contact was provided the same information as the dealer and the contact was given a case number. The vehicle was repaired. The failure mileage was unknown.

2011-2013 Sonata (yf) and airbag control unit (recall campaign 174) I did the recall at sterling mcall in 10/2022 and I had no airbag light before after I did the recall the airbag light came on the dashboard -the dealers scanned the car and it is visible on the baseboard however the dealer is reluctant to repair it and asked 3 weeks of diagnostic and 500 dollars only for diagnostic and nothing about the repair I showed them the recall repair failure is their responsibility and the airbag should be permanently fixed not to be worried about it from time to time the dealer's excuse is that car titles salvage however the car is being serviced at the dealer and is passing state inspection every year. I filed a complaint in bbb nad the dealer failed to respond and sent me a threatening letter for emailing their executive.

See all problems of the 2012 Hyundai Sonata 🔎.

Sterling mccall Hyundai at houston 77074 installed an airbag unit as part of a recall last visit. The airbag light came, and I went to the dealership to fix the light, they said they were not responsible, and they wanted a $490 inspection cost plus the repair, and I had to leave the car for 3 weeks. They scanned the car and airbag showed on the dashboard the dealership must install genuine parts that do not require fixing every couple of months, which is their responsibility. I am flagging the belvoir on my recall so far. This is not a good reputation for your company I hope this is done urgently to avoid further issues and we maintain a good relationship rather than fighting.

My seatbelt in the front seat does not work effectively. My airbag light is on recall 169 anchor pretensioner inspection is the recall I see that is associated with my seatbelt recall 174 airbag control unit is the recall that I see associated with the airbag light both recalls say they are completed. I called the Hyundai dealership and they said reach out to the manufacturer because there are no open recalls on my car. Both are safety concerns that I hope can get addressed.

The contact owns a 2008 Hyundai Sonata. The contact stated that the air bag warning light was illuminated. The vehicle was taken to the dealer to be repaired under NHTSA campaign number: 08v161000 (air bags); however, the dealer informed the contact that he had to pay for a diagnostic test prior to the recall repair. The contact declined. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 181,000.

See all problems of the 2008 Hyundai Sonata 🔎.

Vehicle went over a pothole where the manhole cover was few inches above ground. Vehicle was traveling at 15 mph. The driver side seat and airbags deployed on it went over the pothole.

The contact owns a 2014 Hyundai Sonata. The contact stated while driving at an undisclosed speed, the air bag warning light illuminated. In addition, the contact stated that the horn independently beeped. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 63,000.

The hybrid warning system came on. The ready light is blinking and beeping. The car is jerking.

A light on the dash went on and we were told it was the airbag clock spring steering column. At cost of over $900 we had to have it repaired. There were previous recalls on the Hyundai Sonatas for this part and I think it should be covered. The car has only 60,000 miles on it.

See all problems of the 2017 Hyundai Sonata 🔎.

Airbag clock springs module malfunction disabling emergency deployment of the driver’s side airbag in the event of a collision. My 2012 Hyundai Sonata 2. 0 turbo with 93,336 miles on it, ending seized up going at highway speed causing instant and complete loss of power. Smoke started coming out from under the front engine compartment hood making me think the car was on fire. Trying to get the car manuvered off the highway and over to the right side of the road I was almost involved in a collision with other traffic. I was scared almost to death. Hyundai motor America is now refusing to repair my vehicle even though it is covered under their extend warranty.

With a front seat passenger, using the autos seat belt, at the height of 5’ 6” and a 145lbs. The airbag off light will come on, indicating the airbag system has been turned off. This is intermittent and at times the issue can be resolved with pulling the vehicle over. Turning the engine off, asking the passenger to step out of the vehicle (at times on the shoulder of a major interstate), closing the front passenger door. To then reopen the car door, set again in the front passenger seat, secure seat belt and the driver starts the car. Sometimes this will cause the light to go off, indicating the airbag system is on. However, this does not always work. During a normal transit the airbag will randomly come on and off.

See all problems of the 2024 Hyundai Sonata 🔎.

I have own my Sonata for 4 years and haven't had any problems mechanical or electrical safety. Due to my car being a Sonata and part of the settlement against them for faulty security alarm system on their cars. I was advised to make an appointment at the nearest dealer so my car alarm system car be upgraded to anti theft logic system as part of the settlement agreement. I haven't had my car stolen but was already worried about them touching my car electrical system. Boy my gut was right. I scheduled an appt to get the upgraded theft system installed and two days later my passenger air bag light came on. I have never seen this light on before so I did my research and found out that this means in a crash whoever is sitting on the passenger side air bags will not deploy. Being a father of three young ladies that drive them to school. I was very concerned so I contacted Hyundai corporation to let them know of my concerns and car situation. I spoke to a case manager ashley was really nice collecting the information and initially understood my concern being that I have had zero issues with the car. Ashley advise I make another appt to have them inspect the system and she would follow up with me. I did so and the tech said it's a faulty error for the safety air bag module that it will not work on the passenger side. I explained that I have had many cars over the years but never have I had a faulty airbag error. So I asked, have anyone else experience this error after getting the anti theft upgrade? he was quite and proceed to then disclose that my car is at 66k and the warranty ended at 60k for my car. I ask him why should I have to pay for something that was working fine up until the anti theft upgrade down by them. No response. Ashley called me and stated that they will not complete the repairs because I have not done my regular car maintenance at this location. I asked what the maintenance for a electrical issue cause after the anti theft upgrade. Hyundai has lost me.

Airbags light shows up on the dashboard one day and it won’t go away, I was just driving and it came on. No collision has occurred causing airbag light to come on.

I started my car and my steering wheel airbag deployed within a few seconds and injured me. Reason for deployment unknown.

While driving on expressway the red air bag light went on for no apparent reason and will not turn off. I tried to reset by disconnecting the car battery, but it's still on. This happened about 2 months ago. The car has never had a bag actuate I had heard that air bag malfunctions and some emission problems are covered regardless of age or mileage as long as they have not been tampered.

Dashboard cracked passenger seat around airbag word. Before weather got very hot outside was sitting in parking lot engine off, heard a loud noise and was not able to locate anything wrong. Thought it was the windshield that has a small crack in it. Noticed nothing. Several days later saw large lines through windshield around airbag. Looked inside car to see better. Several weeks later saw smaller crack on driver side dash nearest to door area. Did have oil changed on car on 4-19-24. This happened weeks later (the cracks). Did notify repair shop (auto dealer priority) of issue. Next appt was 5-18-24 for new tires to be put on car.

I am having an issue with the driver's front airbag clock spring assembly in my 2014 Hyundai Sonata. I see that there is a recall on the 2011-2014 elantra vehicles, 2011-2013 Sonata vehicles, and 2011-2014 Sonata hybrid vehicles for up to 15 years, but my 2014 Sonata is having the same issue. My car is not a hybrid, but what do I need to do in order to get this covered? everything that the recall is describing is going on with my vehicle. The airbag light stays on, a non-functional horn, and/or inoperative steering wheel controls, the steering column makes a noise when turned.

The air bag sensor located in the front passenger seat does not function. It is available for inspection upon request. Because the sensor doesn't engage, the passenger-side air bag will not deploy in the event of an accident, leaving my passenger at risk of serious injury or death. The Hyundai of cool springs dealership in franklin, TN, has inspected the car and confirmed that the sensor is not functioning. The sensor, if properly working, will show a glowing red light on the dashboard that goes on when a passenger sits in the passenger seat, and goes off after a few seconds. In the case of my car, however, the dashboard light goes on when a passenger sits and stays on (glowing red) the entire time the passenger is seated. This defective dashboard light, according to the Hyundai service technician, indicates that the sensor needs to be replaced. The cost the technician quoted is prohibitive at $3,500.

See all problems of the 2015 Hyundai Sonata 🔎.

Intake camshaft, camshaft position actuator circuit and brake booster are the system that failed all in the same week. My safety is being put at risk because of the bad brake booster I almost rear end someone else. My car doesn’t accelerate has it should initially which could cause a wreck. Problems has been confirmed by independent service center. My car has been inspected by mechanics. My engine light is on and when diagnosed the codes p0011-00 & p0010-00 pop up.

Airbag light came on. Car is in otherwise perfect shape (red flag). Brought to Hyundai dealer. Was told it was a short somewhere on front passenger side. But it will cost $250 to figure out where. Then possibly over $1000 to fix it!! upon researching it I found many complaints on same issue on otherwise normal good condition Sonata’s. Clearly they used inferior components designed to fail. Similar to their stealable cars (with a usb cable) I’m sure you’re fermi liar with. They hid that until tic tok put out videos showing how to. They had to fix it due to owners auto insurance going up (way up). I can’t afford to repair this pressing safety issue. Hyundai should be held responsible for using knowingly faulty parts in their air bag system then charging customer large $ just to make an otherwise perfectly running car safe to operate. Oh, then they said they’d offer me a “loaner” till fixed. But their “loner” costs $50 per day!! that’s a rental not a loaner.

The brake lights keep going off, they have been replaced several times. The passenger airbag deployed on a stop sign and cracked the entire windshield. The steering wheel feels like it’s going to come off. Please help.

Vehicle was left in care of dealership service department after critical failure of engine. Determined that recall 162 was responsible and Hyundai would afford the repair. Vehicle at dealership for 5 months until repair could be scheduled. Repair complete, dealership advised us that the airbag light was illuminated. Technician performed "courtesy" diagnostic to read codes. Codes b1329 and b1331; front impact sensor and passenger communication error. Neither code is historic for the vehicle and only displayed after service from dealership.

The contact owns a 2019 Hyundai Sonata. The contact stated that the air bag warning light warning light had been illuminated. The contact stated that while pulling on the seat belt, the warning light deactivated; however, the warning light activated shortly after. The vehicle had not been taken to the dealer. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The failure mileage was 60,000.