Alternator/generator/regulator Problems of Toyota RAV4

The contact owns a 2010 Toyota Rav4. The contact stated while driving 35 mph, the steering wheel inadvertently locked and the vehicle loss power. The steering warning light was illuminated. The contact stated he was able to veer to the side of the road while driving downhill. The vehicle was towed to the dealer who diagnosed that the alternator needed to be replaced. The manufacturer was made aware of the failure and informed the contact that they could not provide any assistance as the vehicle was out of warranty. A case was opened. The vehicle was not repaired. The approximate failure mileage was 162,000.

See all problems of the 2010 Toyota RAV4 🔎.

The contact owns a 2008 Rav4. The contact stated while driving 5 mph, there was smoke coming up the windshield. There was no warning light illuminated. The contact pulled over to inspect the vehicle and became aware that the alternator was smoking. The vehicle was turned off and towed back to the residence. The contact purchased the alternator and fixed the vehicle. Neither the dealer nor the manufacturer had been notified of the failure. The approximate failure mileage was 126,000.

See all problems of the 2008 Toyota RAV4 🔎.

Whether I'm driving or parked with the engine running, the car shuts down completely. I cant turn on the hazard lights or roll down the power windows. I have no lights whatsoever, so no one can see me at night. I had the car towed to the dealership after a bus almost rear-ended me. Previously they replaced the alternator. That did not fix the problem. They cannot fix my car.

See all problems of the 2007 Toyota RAV4 🔎.

I was traveling down arrow hwy in the rain when my electrical system failed. I lost power from both my alternator and battery intermittently. I was coasting down to an approaching intersection when I made the descision to turn right at the intersection. The steering was so hard that I nearing hit the center divide. My windshield wipers were barely working and many of my dash icons were coming on randomly. Through it all, my engine continued to run and I made to the next street that turned into condos that had parking spaces. I shut my engine off and tried a restart. The engine,of course,did not start. After being hauled to the nearest Toyota dealer they diagnosed the problem as an alternator that shorted the battery. Having a little experience in this electrical area, I understand how this can happen but with proper design it could have been avoided. The battery was saved after recharging. Here is my point; I don't want any one that I know and love to go through what I had to. Those that drive this car should be made aware that this could happen with a car equipped with electrical steering. This problem could have been more severe if the engine would have stalled; which, by the way would have happened in a short time.

While traveling westbound on interstate 295 in jacksonville florida, we had just got on to the buckman bridge when the car slowed, uncommanded to 20mph. I looked at the instrument cluster and the alternator and the auto lsd or track lights were illuminated. The engine operating temperature was normal. Since the engine temperature was normal I told my daughter to keep driving to get off the bridge, I felt as though the bridge was a bad place to pull over. After about a minute we started to smell something burning and at this point we decided to pull over. When we came to a complete stop we saw smoke coming from the drivers side of the engine compartment. Three of us then evacuated the vehicle and started walking against traffic on the bridge. As we were walking away the smoke intensified and then erupted into flames that emanated from the drivers side just below the windshield. I called 911 and the fire department came and extinguished the fire. I have attached pictures of the damage. I believe it was an electrical fire.

See all problems of the 2014 Toyota RAV4 🔎.

The contact owns a 2008 Toyota Rav4. While driving 45 mph, the engine stalled without warning. The contact could not pull the vehicle over to the side of the road. The contact turned off and restarted the vehicle, and it returned to normal. The vehicle was not taken to the dealer. The vehicle was taken to an independent mechanic where it was diagnosed that the alternator, battery, and ignition switch needed to be replaced. The vehicle was repaired. The contact also stated that the failure recurred several other times after the repair. The vehicle was not taken to an independent mechanic or to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was contacted at 800-331-4331 and asked the contact to take the vehicle to the dealer. A case number was not provided. The approximate failure mileage was 213,000. The VIN was not available.

The contact owns a 2010 Toyota Rav4. The contact received notification of NHTSA campaign number: 15v577000 (visibility/wiper). The vehicle was taken to galaxy Toyota dealer, located on 750 NJ-36, eatontown, NJ 07724 (732) 544-1000, where it was repaired. The contact stated that when she had picked up the vehicle and there was a noise coming from the front of the vehicle. The contact took the vehicle back to galaxy Toyota dealer, where it was informed that the alternator failed and needed to replaced. The vehicle was not repaired due to the repair fees. The manufacturer was not made aware of the failure. The approximate failure mileage was 132,000.

I have 2006 Toyota Rav4-battery warning lights flips and go,- when I was driving in freeway 68mph, battery warning signals flips two times while I try to accelerate the vehicle. And also all warning signals, check engine, tcs, vsc, 4 wd, break, and airbag signals came and vehicle lost all electrical power, steering become hard and break didn't work, I had to pull over the vehicle in freeway. It happed two times, still the battery signals are flips when push the gas. I had to tow this vehicle two times. I check this car with three mechanics and autozone, they could not find out any problem,. They all said battery and alternators are working good ( battery and alternators are replaced two ears ago. I have seen many 2006 Toyota Rav4 customers experiencing the same problem. Driving this vehicle is scary and life threatening. I hope highway safety is; aware of this problem and they will make an enquiry/action.

See all problems of the 2006 Toyota RAV4 🔎.

Drove for over an hour in dry, stable weather conditions. Upon slowing to make a left turn into a parking garage on surface streets the steering completely stalled with multiple alarm lights flashing, including battery. Vehicle was still on and able to drive but with very poor acceleration. This caused me to block traffic oncoming traffic for over 10 minutes as I labored (with a lot of strength) with the stalled power steering back and forth until inline with the garage. Called triple a immediately and had battery changed. Despite the car working again with stable steering, still concerned about stalling again, particularly in city streets (including the sf hills) and freeways. There needs to be some fix for power-steering being the first thing to fail with the battery/alternators.

2006 Toyota rav 4. Consumer writes in regards to disappointment with alternator repair work at dealership. The consumer stated she did not think she needed an alternator replacement. After the alternator was replaced, the battery light illuminated. According to the invoice, the dealer replaced the short engine block. The dealer not charge the consumer for the replacement of the alternator and engine short block. However, there was a charge for an engine gasket and cylinder.

The contact owns a 2007 Toyota Rav4. While driving at unknown speeds, the battery light illuminated and the power steering malfunctioned. The vehicle was taken to an independent mechanic. The technician diagnosed that the alternator and battery needed to be replaced. The manufacturer was made aware of the failure. The vehicle was not repaired. The failure mileage was 88,000.

While sitting in slow 5-10mph traffic on the freeway, the power steering seized and the airbag dashboard warning light came on at the same time (for about 2-3 seconds at a time). A few miles later, other warning lights (vsc, slip, abs, engine, battery) all illuminated on and off randomly. Took it to the mechanic to have it looked at. They replaced the battery, but the problem happened again about 12 hours later. The alternator is a year old and the battery, tires, alignment, and engine coils are all brand new. After half a dozen calls to the dealership, come to find out, the problem is the computer that controls the power steering. . . A problem which has been acknowledged and recalled for 2014-15 model year Rav4s. This is a serious safety flaw, and it is insulting and negligent that Toyota is pretending this isn't a serious problem for other model years.

All dash lights turned on and steering wheel was hard to turn. Drove home. Restart the vehicle, no issues, left it running, it happened again and smelled a burning smell. Had it towed to Toyota dealership. They replaced battery. Yesterday 11-18-14, same issue going about 40 mph. Had it towed to same dealership. Alternator needs to be replaced. Toyota also informed that water pump is failing. Through internet research, these are extremely common issues that should be resolved by Toyota and people should be reimbursed for such an extensive problem.

My 2007 Toyota Rav4 was being driven by my wife and she noticed indicator lights suddenly coming on the dashboard and the vehicle sputtering and starting to stall. Prior to the vehicle stalling, she noticed the power steering inoperable and she was having difficulty steering to bring the vehicle to the shoulder lane and to a stop. She called me and I called for emergency roadside assistance. The vehicle was restarted. At this time, as the engine ran, the power steering was still inoperable and the vehicle was undrivable. It was then towed home. My mechanic checked and found the battery to be undercharged due to a defective alternator not properly charging the battery. The battery and the alternator was replaced and the power steering and all other functions resumed back to normal. My safety concern is that the power steering unit should not have stopped functioning as long as the engine was in operation. If the braking system continued to operate normally as the engine ran, the power steering unit should also continue to operate so that the driver can stay in complete control of the vehicle. If my wife was traveling at a higher rate of speed and on a busy interstate freeway, the outcome could have been disastrous. Please look into getting Toyota to recall and correcting this safety issue on mine and other 2007 Rav4s. Thank you for your assistance. A reply would be greatly appreciated.

Alternator fails at 45000.

I was making a slow speed turn when, without warning, it became very difficult to steer, as if the power steering quit working. As I accelerated the steering started working again. A few days later it happened again and this time the battery warning light came on. Both times this happened it almost caused a collision. I ended up taking it to the dealer and learned the alternator was going bad. An alternator on a four year old vehicle with 60k miles should last longer. I've since learned, from safety sites, that this is a common safety issue with the rav as the steering is electrically powered. There is also some indication the alternators are failing too soon.

The contact owns a 2008 Toyota Rav4. The contact stated that the battery was defective. The battery was replaced twice due to acid leaking however, the failure was not corrected and as a result, battery acid leaked onto the alternator, the engine cover, and the hoses. The failure caused all of the parts to corrode. The vehicle was not repaired. The failure mileage was 75,000 and the current mileage 83,000.

Last night, my Rav4 battery died due presumably to the rear door light getting accidentally turned on. Upon jump starting the car, everything seemed fine. I drove it home without incident. Then, this morning, the battery was not quite up high enough to start the car, so I jump started it again. It started, but a few hundred feet away, I lost power steering and power brake assist. It required every ounce of force I could muster to turn the vehicle around and get it back to my house. Thankfully, this happened on city streets near my house and not on the highway last night or the chp would have been scraping me off a bridge post. The Rav4 cannot realistically be steered by an average person without the power steering assist because of the gearing ratio, making this a very serious design defect. If a vehicle cannot safely operate, the vehicle should not operate. The problem is that, because the battery plays an integral role in power smoothing, and because the power steering and power brake pumps are electrically operated, a low battery can result in failure of the power steering and brake pumps while the engine is still functional. This can easily result in an uncontrollable vehicle barreling down the highway at 80 mph. I believe that fixing this problem requires a fundamental redesign of the electrically operated pumps to add additional capacitors so that the battery is not playing such a crucial role in smoothing out the pulsating DC from the alternator along with the addition of sensor hardware to detect a low battery condition and activate an indicator light until the vehicle is safe to drive. Ideally, the steering gearbox should also be redesigned with a lower gear ratio so that it does not become undriveable. Without these fixes, the 2007 Rav4 is fundamentally unsafe. This design flaw probably also affects most other late models of Toyota.

I purchased a new 2007 Rav4 from Toyota of braintree in 2007. 1. In 2009 I could hear wind in the driver's window; I took the vehicle to be checked, Toyota service department said I was hearing things. 2. The driver's door caught fire (I had the keys with me) I had to spend $606. 01 to fix it, Toyota said there was water intrusion (I thought, it probably was, because of the air leak previously reported in 2009) 3. The steering wheel felt strange when I drove, I took it back for service, the diagnosis was steering shaft internal failure which needed to be replaced; I fought to get that fixed out of warranty. 5. On November 25, 2011 I was driving, the window fell in on me and on November 26, 2011, I had to have the driver's side window regulator replaced for $338. 30 7. Now, oil is leaking into the muffler. (I purchase oil frequently) this vehicle is only 4. 5 years old and should not have any of these major problems, when I purchased this Rav4, it was going to be my last vehicle purchase because Toyota advertises longevity of their products. I also know people who drive 1990 and 1995 Toyota products who have never had any of these problems. I was also treated very poorly during some of my repair visits. After the door caught on fire, I had a meeting with the owner of Toyota of braintree, [xxx] but his resolution was giving me $13,000. 00 for my vehicle (which I own) and me purchasing a brand new vehicle, which meant I would have a monthly payment. I did contact Toyota headquarters in California and filed a complaint and never received any resolution. Since then I received a letter from the national center for dispute settlement stating they can't help me. Thank you for any assistance, sincerely, Toyota Rav4 owner. Information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).

The connection to the alternator was heavily burnt causing loss of power to the vehicle, the consumer was trapped in the vehicle for 1/2 hour prior to the police dept. Arriving to help the consumer out of the vehicle, possible design flaw that did not allow for the consumer to exit vehicle under power loss.

See all problems of the 1999 Toyota RAV4 🔎.