Tank Filler Pipe And Cap Problems of Dodge Durango - part 1

The contact owns a 2005 Dodge Durango. The contact stated that after driving over a bump in the roadway, the gear shifter became inoperable. The vehicle was taken to an independent mechanic where the vehicle was repaired. The contact stated that recently, after depressing the brake pedal, the vehicle stalled without warning. Additionally, while refueling the vehicle, fuel overflowed due to a defective fuel filler neck. The contact linked the failures to NHTSA campaign number: 05v460000 (power train) and 05v034000 (fuel system, gasoline) however, the VIN was not included. Neither the dealer nor the manufacturer were notified of the failure. The vehicle was not repaired. The failure mileage was approximately 130,000.

See all problems of the 2005 Dodge Durango 🔎.

The contact owns a 2005 Dodge Durango. The contact stated that while refueling, fuel spilled out from the filler neck. The vehicle was not taken to the dealer. The manufacturer was made aware of the failure, but offered no assistance since the vehicle was not included in the recall associated with NHTSA campaign id number 05v034000 (fuel system, gasoline:storage:tank assembly:filler pipe and cap). The vehicle was not repaired. The failure and current mileages were 44,000.

While fueling the car at the gas station I keep continuing to have back-flow of gas when filling up. It is happening every-time and I think this is not a safe thing to have gas coming flying back out and getting over the ground. This is a real safety hazard. I have found there is a lot of issues with the 2005 models and now the 2006's are having the same problem. The inquiry is rq08005 and the recall is 05v034000 (fuel system, gasoline storage tank assembly filler pipe and cap). We need to pressure them to fix this issue for all the Durango's.

See all problems of the 2006 Dodge Durango 🔎.

While driving my vehicle, coming to a stop, or turning left at slow speeds 0-5 mph my engine stall without warning. No lights light up on the dash to indicate a problem. I have also noticed that rpms fluctuate (increase/decrease) while my foot is off the gas pedal. This is a daily occurrence. I first thought that I had bad fuel and put an fuel additive in the tank to hopefully resolve the problem. When the problem continued, I replaced the air filter, but the problem continued. I am now going to replace the egr, but I have seen that others have done so without any success in resolving the problem. Based on the notices placed here and at various other web-sites for several years running, it appears that Dodge does not have any procedures in place to resolve this problem. This is a health and safety issue that needs to be addressed. I purchased this vehicle for the purpose of transporting my grand kids, and lacrosse players to and from various events. If Dodge does not resolve this problem, and I or someone I am transporting is injured or killed in a accident based on the above mentioned vehicle malfunction, Dodge will be held accountable.

The contact owns a 2005 Dodge Durango. The contact stated that while refueling, fuel spilled out from the filler neck. The manufacturer was notified and stated that the VIN was not included in the recall associated with NHTSA campaign id number 05v034000 (fuel system, gasoline:storage:tank assembly:filler pipe and cap). The dealer was not notified. The vehicle was not repaired. The failure mileage was 70,000 and the current mileage was 72,000.

The contact owns a 2005 Dodge Durango. The contact stated that fuel would spill out from the filler neck while refueling the vehicle. The failure recurred whenever the vehicle was refueled. The vehicle was not taken to a dealer to have the failure diagnosed. The manufacturer was made aware of the failure and stated that the vehicle was not included in the recall associated with NHTSA campaign id number 05v034000 (fuel system, gasoline:storage:tank assembly:filler pipe and cap). The vehicle was not repaired. The failure mileage was 74,000. Updated 02/06/bf the consumer stated fuel gushed from the filler neck every time he filled up. Updated 03/05/12.

The contact owns a 2005 Dodge Durango. While fueling, the contact noticed fuel spill back out of the vehicle from the filler neck. The vehicle was not taken to the dealer for a diagnostic test. There were two recalls under NHTSA campaign id numbers 05v034000 (fuel system, gasoline:storage:tank assembly:filler pipe and cap) and 09v003000 (fuel system, gasoline:storage:tank assembly), that may be related to the failure. The manufacturer stated that the vehicle was not included in either recall. The VIN was not available. The vehicle was not repaired. The approximate failure mileage was 100,000.

The contact owns a 2006 Dodge Durango. The contact stated that when she attempted tore fuel the vehicle, the pump would shut off and gas would spew back out onto from the filler neck valve. The contact referenced NHTSA campaign id number: 05v034000 (fuel system, gasoline:storage:tank assembly:filler pipe and cap) but did not confirm if the vehicle was included in the recall. The vehicle was taken to the dealer who was unable to duplicate the failure. The manufacturer was not notified of the failure nor was the vehicle repaired. The current mileage was 69,000 and the failure mileage was 68,000.

The contact owns a 2005 Dodge Durango. The contact stated that fuel was spilled from the fuel tank during refueling. The vehicle was not taken to the dealer. The manufacturer was contacted and they confirmed to the contact that the VIN did not qualify for repairs under NHTSA campaign id number:05v034000 ( fuel system, gasoline:storage:tank assembly:filler pipe and cap). The vehicle was not repaired. The failure and the current mileages were was 77,550.

The contact owns a 2006 Dodge Durango. The contact stated that fuel would spill out from the filler neck while refueling. The dealer informed the contact that the check valve failed and advised him to replace the fuel tank. The manufacturer did not offer any assistance since the VIN was not included in the recall associated with NHTSA campaign id number 05v034000 ( fuel system, gasoline:storage:tank assembly:filler pipe and cap). No repairs were performed. The failure mileage was 62,000 and the current mileage was 65,000.

The contact owns a 2005 Dodge Durango. The contact stated that while refueling, fuel would escape from the vehicle filler neck and onto the ground. The dealer and the manufacturer were notified of the failure and advised that the vehicle was not included in the recall associated with NHTSA campaign id number: 05v034000 (fuel system, gasoline:storage:tank assembly:filler pipe. The vehicle was not repaired. The failure mileage was 50,000 and the current mileage was 123,000. . . Updated 04/16/12.

The contact owns a 2005 Dodge Durango. The contact stated after adding gasoline to the fuel tank the fuel would spill out of the vehicle. The vehicle was not inspected by a dealer nor had it been repaired. The manufacturer was contacted and advised him that he was not included in NHTSA campaign id number 05v034000 (fuel system, gasoline:storage:tank assembly:filler pipe and cap). The failure mileage was approximately 90,000.

The contact 2005 Dodge Durango. The contact stated that fuel began to spill out from the filler neck while refueling. The vehicle was not taken to have the failure diagnosed. The manufacturer was made aware of the failure and informed the contact that the vehicle was not included in the recall associated with NHTSA campaign id number 05v034000 (fuel system, gasoline:storage:tank assembly:filler pipe and cap). The vehicle was not repaired. The failure mileage was 92,000 and the current mileage was 93,300.

The contact owns a 2005 Dodge Durango. The contact stated that while refueling, fuel leaked from underneath the vehicle. The fuel cap and engine warning light also illuminated on the instrument panel. The vehicle was not taken to the dealer for a diagnostic test. The contact replaced the fuel cap, but the failure continued. There was a recall under NHTSA campaign id number 05v034000 (fuel system, gasoline:storage:tank assembly:filler pipe and cap), that may be related to the failure. The manufacturer was made aware of the failure and stated that the VIN was not included in the recall. The vehicle was not repaired. The approximate failure mileage was 50,000.

The contact owns a 2005 Dodge Durango. The contact stated when adding fuel to the vehicle, gasoline was spilling out of the fuel tank. The contact took the vehicle to the dealer to be inspected and was told that NHTSA recall campaign id number: 05v034000 (fuel system, gasoline: storage: tank assembly: filler pipe and cap) was related to the failure; however, the vehicle was not included. The current mileage was 89,000.

When filling up the gas tank extra gasoline is spit out of the tank which is a fire issue for the gas station. If we are filling the gas tank, when the pump automatically stops gas pours back out of the tank. Also the gas cap light came on recently & the gas cap was replaced but light came back on. I believe this would be the same recall as the 2005 Dodge Durango fuel system gasoline storage tank assembly. We are taking the truck to the dealer in little falls, NJ on Monday, December 26, 2011 for the repairs to be made. If you search the internet you will find other Dodge Durangos with the same issue. There is a youtube video of a 2007 Dodge Durango demonstrating what happens at the end of filling the tank. . Read more...

See all problems of the 2007 Dodge Durango 🔎.

The contact owns a 2005 Dodge Durango. The contact stated that fuel spilled from the filler neck while refueling. The vehicle was not taken to have the failure diagnosed or repaired. The manufacturer was made aware of the failure and the contact was informed that the vehicle was not included in NHTSA campaign id numbers: 09v003000 (fuel system, gasoline:storage:tank assembly) or 05v034000 (fuel system, gasoline:storage:tank assembly:filler pipe and cap). The failure mileage was 110,000.

The fuel tank filler tube inlet check valve does not fully close at the end of refueling. It allows some fuel to escape from the vehicle filler neck. Now the gas cap light message stays on and the check engine light came on and stays on. This was a recall for the 2005 Durango mine is a 2007 is this recall still active for my vehicle?.

On numerous occasions when filling my gas tank the automatic shut off ( that tells you the tank is full) has not kicked in causing the tank to over flow and kick back gas spray all over me, my fiance, or the attendant at the gas station. This is not something that has happened just once, but multiple times in the 9 months I have owned this vehicle. I have checked for recalls and my VIN comes back with no active recalls, I even went as far as reading in detail the NHTSA recall reports (09v003000 and 05v034000) to obtain manufacture dates to compare against my own. Needless to say mine does not fit in the date range (3/1/04-11/30/04) having been manufactured in February 2005, but does infact have the same issue as the models under recall. This is something I want to have fixed but don't feel I should have to pay to do so seeing as this is an issue they knew they had and claimed to have fixed but quite obviously did not. I am tired of being afraid to fill my gas tank and getting covered in gas when I do.

The contact owns a 2005 Dodge Durango. The contact stated that while refueling the vehicle, gasoline would spill back out. The dealer was notified and stated that the VIN was not included in NHTSA campaign id number: 05v034000 (fuel system, gasoline: storage: tank assembly: filler pipe and cap tact). The manufacturer was notified and confirmed that the VIN was not included in the recall. They offered no other assistance. The failure mileage was 109,000.

The contact owns a 2005 Dodge Durango. The contact stated that while refueling the vehicle, fuel would spew from the vehicle, splashing onto the contact and the vehicle. The contact referenced NHTSA campaign id number: 05v034000 (fuel system, gasoline:storage:tank assembly:filler pipe and cap) and stated that the vehicle was taken to the dealer for repairs. The dealer however, advised that the vehicle was not included in the recall. The dealer also informed the contact that the fuel tank would need to be replaced due to a faulty check valve. The contact stated that the fuel spewing from the tank could possibly result in a fire. The failure mileage was 92,288.

The contact owns a 2005 Dodge Durango. The contact stated that fuel spilled out of the fuel tank whenever it was added to the fuel tank. The contact also noticed NHTSA recall campaign id number: 09v003000 (fuel system, gasoline tank: assembly), but the manufacturer stated the vehicle was not included. The failure mileage was 120,000 and the current mileage is 130,000. Updated 11/17/11 updated 11/23/11.

The contact owns a 2005 Dodge Durango. The contact stated that when he added gasoline to the fuel tank, the automatic shutoff valve did not function and the fuel spilled out of the filler neck. The failure occurred every time the tank was full. The vehicle was taken to an authorized dealer who stated that the vehicle was not included in recalls 05v034000 (fuel system, gasoline:storage tank assembly:filler pipe and cap) and 09v003000 (fuel system, gasoline:storage:tank assembly). The vehicle was not repaired. The contact called the manufacturer and filed a complaint. The current mileage was approximately 43,200. The failure mileage was approximately 42,000.

My 2005 doge Durango sprays gas out of the gas tank eveytime I fill up my car. Despite that fact that there is a open recall on the fuel tank filter for the 2005 Dodge Durango, crysler/Dodge said that my SUV does not qualify for the recall since it has a different part numebr. Therefore, even though my car exhibits the exact same issue as the outstanding recall and also presents a significant safety issue crysler/Dodge is unwilling to include my SUV and countless others in the recall and instead is saying that I need to fix the safety issue and the charge is $1665. 00.

While pumping gas into my 2006 Dodge Durango limited, the fuel hose shut off sensing that the tank was almost full however the fuel came spewing out of the tank from the vehicle. Approximately 1/4 of a gallon of fuel spilled out onto me, the vehicle, tail pipe and the ground. This has happened now five times in a row. This could be a fire hazard, and definately a chemical burn on my hands and uncovered feet. There is a recall for the 2005 model year, but the dealer said mine is not covered under that recall.

The contact owns a 2005 Dodge Durango. The contact was refueling the vehicle when the nozzle shut off and gasoline began spewing from the vehicle filler neck. The contact assumed the failure was caused by the fuel pump and the vehicle was taken to a second gasoline station where the failure recurred. The vehicle was then taken to the dealer who diagnosed that the molded valve and control valve was failing and the tank would need to be replaced. The manufacturer was contacted but offered no assistance. The vehicle was not included in the recall associated with NHTSA campaign id number: 05v034000 (fuel system, gasoline:storage:tank assembly:filler pipe and cap). The vehicle was not repaired. The failure and current mileage was 97,605. Updated 03/31/lj the consumer stated after a few phone calls, Chrysler agreed to pay for the defect, minus 150. Updated 05/23/11.

Tl-the contact owns a 2005 Dodge Durango. The contact stated while fueling the vehicle the fuel spills to ground. The contact stated the fuel tank has to be filled to half to avoid the fuel spill. The vehicle was taken to the dealer who performed a diagnosed that located the failure at the gas tank assembly. The manufacturer was contacted and they advised the vehicle was not included in recall NHTSA campaign id number: 05v034000 component: fuel system, gasoline: storage: tank assembly: filler pipe and cap. The vehicle has not been repaired. The failure mileage was 55,000 and the current mileage was 63,000. Li.

I have a 2006 Dodge Durango and when you fill the fuel tank, fuel gushes out of the pipe when the pump shuts off. This happens every time. It is the same thing that the 2005 Durangos were recalled for. I'd like mine recalled. 2005 recall NHTSA campaign number: 09v003000 and09v003000. The fuel tank filler tube inlet check valve may not fully close at the end of refueling. This could allow some fuel to escape from the vehicle through the filler neck at the end of refueling.

The contact owns a 2005 Dodge Durango. The contact stated that when attempting to refuel the vehicle, gasoline would spew back out. The failure was similar to that which was described in NHTSA campaign id number: 05v034000 (fuel system, gasoline:storage:tank assembly:filler pipe and cap). The dealer was notified and the contact was awaiting a response. The contact did not inform the manufacturer nor was the vehicle repaired. The current mileage was 66,000 and the failure mileage was 64,000.

The contact owns a 2005 Dodge Durango. The contact stated that after dispensing fuel to the full capacity, the fuel would spew out of the filler neck and onto the ground. The contact referenced NHTSA campaign id nummer: 05v034000 (fuel system, gasoline:storage:tank assembly:filler pipe and cap) and stated that the VIN was not included in the recall. The vehicle was not repaired. The failure mileage was approximately 206,000. Updated 05/05/lj.

The contact owns a 2006 Dodge Durango. While fueling the vehicle, approximately a quart of fuel spilled out. The failure had been on-going since December 2010. The vehicle was taken to the dealer for the failure and they advised him that the fuel filler tube and filter needed to be replaced. The contact referenced recall 05v034000 (fuel system, gasoline: storage: tank assembly:filler pipe and cap and stated he was having the same failure. The vehicle had not been repaired. He contacted the manufacturer and was advised to file a safety complaint. The failure mileage was 81,000 and the current mileage was 85,914.

I own a 2005 Dodge Durango slt 5. 7 liter v8. I have approximately 43,100 miles on my vehicle. As of right now, everytme I fill up my car, the pump will click off and then gas will start spraying out of the gas tank. It has recently happened three times in a row without fail. It appears it's several cups of gas that sprays out. I have to make sure I am clear of the gas tank pipe or I will be covered in gas. I contacted Dodge with the issue and they informed me that my vehicle did not have any recalls. I did some research on my own and learned that there were two recalls for the same issue. I was advised to file a complaint to let someone know there are still more of these dangerous issues happening. Please help with this issue. It is very dangerous.

At the completion of fueling my 2005 Dodge Durango, the fuel pump will shut off, then 1-2 seconds later approximately 1 cup of fuel will spit back out of the fuel tank. It has occurred 4 time over the past 2 months (each time I fill up). While researching the issue, I came across NHTSA action number rq08005, and contacted Chrysler (case #20241304) who told me to bring the vehicle into delray motors to evaluate. They replaced the filler pipe, charged me $403. 21, but the problem still exists. After returning the car to delray motors, they have made various accusation regard me not represent what the problem was, and now they are saying they will not honor the recall because it was completed in August of 2005 (which was never done). How do I get Dodge/Chrysler to honor this recall?.

The contact owns a 2005 Dodge Durango. The contact stated that every time the vehicle was refueled, fuel would spill out from the tank. The vehicle was taken to a mechanic where the contact was advised that there was a recall for the filler cap check valve on the vehicle. When the contact spoke to the manufacturer, they advised that the vehicle was not included in NHTSA campaign id number: 09v003000 (fuel system, gasoline storage: tank assembly). The vehicle was not repaired. The failure mileage was 160,000 and the current mileage was 183,000.

The contact owns a 2005 Dodge Durango. While adding gasoline to the fuel tank it would spill back onto him. There NHTSA recall #05v034000, fuel system, gasoline storage, tank assembly filler pipe and cap. The dealer was contacted and informed her that her VIN was not included in the recall; therefore she would have to pay for the repairs. The manufacturer confirmed that her VIN was not included in the recall and offered no assistance. The failure mileage was 58,812.