Four problems related to brake disc caliper have been reported for the 2015 Ford F-150. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2015 Ford F-150 based on all problems reported for the 2015 F-150.
Brake pedal going all the way to floor took to dealer he said noting was wrong same day took to local shop they replaced the master clydner and calipers the truck had 36400 miles the repair seam to fix the problem very strange that the dealer did not want to address the issue when coming to a stop break pedal with pressure would go to the floor felt like there was no pedal left by pumping break pedal you could get pressure back but it would go back to floor it also would do this stoped at red light.
I noticed the front passenger brake overheating. The place I bought it from agree to replace pads and rotors. That didn't fix it, took it to Ford and they replaced caliper, but that didn't fix it. Now its at Ford again! front passenger brake overheating even more than before! I'm afraid to drive it with my family in it for fear of potential brake failure/fire! truck is at mullinax Ford on northlake blvd in palm beach gardens florida.
Brakes are rubbing and dealer has reground front disc brakes twice without fixing problem. Suspect that brake calipers are not completely disengaging after brakes are applied. Brake pedal will go all the way to the floor after applying brakes.
I just read an article about the brake failures on the 2015 & 2016 F-150. I have a 2015 F-150 platinum 4x4 with approximately 31,000 miles and experienced a similar event about 2 weeks ago. As I approached a stop signal on my normal route home, the brakes failed when I stepped on the pedal, it acted like the anti-skid brake system had taken over and wouldn't allow the pedal to apply hydraulic pressure to the brake calipers. This was the first and only time it has happened, so I did not report the event to Ford. No damage or injury occurred.