16 problems related to steering noise have been reported for the 2012 Ford Fusion. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2012 Ford Fusion based on all problems reported for the 2012 Fusion.
Loud creaking noise when turning the steering wheel at low speeds. It does not occur when it is cold outside, but occurs at temperature 70+. It get's really loud at temperatures near 80 degrees and above. I am concerned it will fail while driving. Exact same issue as others. When I took vehicle to Ford, it was cold and they said nothing was wrong.
Tl- the contact owns a 2012 Ford Fusion. The contact stated that while driving approximately 70 mph when the vehicle suddenly the power steering failed. The contact pulled over to the side of the road. The contact was unable to regain power steering making it difficult to manuever the vehicle. The contact took the vehicle to certified mechanic who diagnoised that the power steering needed to be repaired, the rac n pinion replaced, computerized alignment. The manufacturer was made aware of the issue. The approximate failure mileage was 154,000. Gl.
Power steering makes a scraping noise when you turn the steering wheel. Sometimes it gets harder to turn and there are noises associated with it. It has happened to me while stationary and while driving when turning. I am afraid that power steering will fail on that car leaving me on the side of the road or even put me at risk for an accident.
Tl the contact owns a 2012 Ford Fusion. While driving 25 mph, the contact heard an abnormal noise and the steering wheel became difficult to turn and the steering assist failure warning indicator illuminated. The contact was able to park on the side of the road and had the vehicle towed to her residence. The contact stated that the vehicle was repaired per NHTSA campaign number: 15v340000 (steering). The contact called pat & dan's delbalso Ford (located at 249 market st, kingston, PA 18704, (570) 288-4501) where it was diagnosed that the steering rate needed to be replaced. The vehicle was not repaired. The manufacturer was notified. The failure mileage was 153,000.
Tl - the contact owns a 2012 Ford Fusion. The contact stated while driving 30mph she heard an abnormal noise and the steering and traction control warning indicators illuminated. The vehicle was not taken to a dealer to be diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 127,000. Jc.
There is a loud creaking noise when turning the steering wheel at low speeds. It does not occur when it is cool/cold outside, but occurs at temperature 80+. It get's really loud at temperatures near 100 degrees and above. I am concerned it will fail while driving.
The contact owns a 2012 Ford Fusion. The contact stated that the steering column made an abnormal popping noise while the steering wheel was being turned. The failure occurred without warning. The vehicle was taken to jim click Ford Lincoln east tucson (6244 e 22nd st, tucson, az) where it was diagnosed that the control arms needed replacement. The vehicle was repaired, but the failure recurred. The manufacturer was not notified of the failure. The failure mileage was approximately 83,000.
Recall 15s18 steering gear, while driving the steering while turning the make a noise . Took it to jim click Ford because a code didn't show on dash Ford will not cover the cost to replace the steering gear which is the issue with the car. So we are unable to drive the car it is dangerous/ unsafe to drive the vehicle. The steering make noise when in motion, stationary on street and highway when turning the steering wheel. Nhtsa #1227804 /Ford case#14458165.
The contact owns a 2012 Ford Fusion. While driving, the contact heard an abnormal noise in the steering area. The air bag warning indicator illuminated on and off. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and the contact was informed of NHTSA campaign number: 17v024000 (air bags). The approximate failure mileage was 68,000.
Popping noise present from steering wheel whenever steering wheel is turned in either direction. Whenever vehicle hits a bump regardless of the size, the steering wheel is yanked around causing the control of the vehicle to become compromised. These issues happen at any speed and in all road conditions, stationary or non stationary, highway or city and regardless if I'm turning or not. When steering wheel is turned all the way to the right or left the wheel will stiffen and throw itself back the opposite direction. Must use a lot of force to keep steering wheel in that position. Was told by a certified Ford dealership and a shop by the name of midas that it was the rack and pinion. Ford refuses to fix issue due to the fact that the rack and pinion is not throwing any sort of trouble code. The rack and pinion on this vehicle however is not only under a current recall but is also backed by an extended warranty issued by Ford motor company.
Tl-the contact owns a 2012 Ford Fusion. The contact stated that while driving at 30 mph and attempting to turn left or right it was an abnormal noise heard from the steering column without warning. . The vehicle was taken to a dealer where it was diagnosed that the power steering control module had failed and needed to be replaced. The vehicle was not repaired. The VIN was not included in NHTSA campaign number: 15v340000 (steering). The manufacturer was notified of the failure. The failure mileage was approximately 78,000. Ec.
Develop a clunking noise in steering system at 82000 miles. Took the car to a ase mechanic in my town and it was diagnosed as a failed epas (power steering rack. ) the bill for this is going to be between 1400-1600! I have read elsewhere online of Ford recalling the Fusion for trouble codes in the same steering rack for failed sensors and loss of power assist suddenly making the car difficult to steer and risking a crash as a result. My concern is complete mechanical failure due to the clunking like something is either broken or about to break. This would result in complete loss of control of vehicle and a possible crash. I realize things break out of warranty but this is a safety issue first and foremost. My daughter drives the car and my concern is for her safety. If there is no recall issued I will be forced to repair or trade the car and lose what little equity I had in the car because of its repair bill. The car has been well maintained. This is not an abuse issue. My opinion is that this a faulty part. When I took it to my local Ford dealer, I was told there were no recalls on the car and I would have to pay the bill out of pocket.
Just got my 2012 Ford Fusion 2 months ago from the lot and while driving it noticed that there was a clicking noise coming from the steering wheel when I turned in to a parking space. . Thought it was a cv joint or bearing. . Come to find out from mechanic that the steering rack and pinion need replaced and would be a 1,700 dollar fix. . Very upset I took this to Ford where they pretty much told me they can not do anything for me as it is not covered under warranty. It really angers me seeing as how this is very common in all the Fusions I have read up on, and that this is an ongoing problem that Ford has not made right at all for any of the Fusion owners 10-14. . Horrible. Do not feel like I should be making such a serious repair like a steering rack for a vehicle that is just 3 years old. Very disappointed and very much so interested in investigating more into the class action lawsuit filed upon Ford for this very problem. Knowing that the steering could go out at any time and possibly kill or seriously injure someone.
For about 3 months kept hearing a knocking noise in the steering column when making turns. Took it to a local Ford company- they checked it out and dx problems that didn't exist and never said anything about the power steering. Then 2-3 weeks ago was driving it came to a stop light the "service electric power steering now" came on- 200 more yards the power steering was gone. Had to have it towed- contacted 2 other Ford dealerships and they said there wasn't a recall at this time. Also contacted the main Ford headquarters and reported it. I now have a car I'm making payments on and can't drive!.
When steering I could hear a noise and I felt shake on steering wheel. Had to take to dealer.
The steering has play and is starting to lock. There is thud noise as I turn the steering wheel right to left and left to right.