Manifold/header/muffler/tail Pipe Problems of Nissan Frontier

Manifolds break apart 2 times since owning the truck.

See all problems of the 2013 Nissan Frontier 🔎.

Tl-the contact owns a 2013 Nissan Frontier. The contact stated while driving approximately 30 mph and approaching a stop, there was an abnormal sound from the front of the vehicle. The contact also stated there was a smell of exhaust fumes inside the vehicle. The vehicle was taken to a dealer for diagnostic testing. The mechanic stated that the intake manifold on the driver side was fractured and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 37,700. Mf.

White smoke coming out of the tail pipe.

See all problems of the 2007 Nissan Frontier 🔎.

The contact owns a 2002 Nissan Frontier. The contact stated that the exhaust manifold was fractured and sending co2 through the vents while driving 25 mph and above. The contact took the vehicle to the dealer and the dealer replaced the passenger side exhaust manifold. After the repairs, the driver side exhaust manifold fractured and the contact took the vehicle back to the dealer. The dealer advised that it was common for the manifold to fracture in the particular year, make and model. The contact did not replace the driver side exhaust manifold. The failure mileage was 150,000.

See all problems of the 2002 Nissan Frontier 🔎.

Right side exhaust manifold cracked and the left side is now cracked. I have owned many Nissan's before and this problem is a design flaw.

See all problems of the 2000 Nissan Frontier 🔎.

Cracked manifold.

Both exhaust manifolds cracked and had to be replaced.

See all problems of the 2001 Nissan Frontier 🔎.

Consumer smelled fumes coming into the vehicle. Consumer took the vehicle to dealer, and the right manifold exhaust was defective. The warranty company stated, not covered under warranty. Manufacturer stated no complaints received.

Exhaust leak in the exhaust manifold. Cast iron manifold is cracked on both sides. Vehicle is only 5 years old. Not covered as emisions problem, cast iron manifolds are defective on my 1999 Nissan Frontier se-v6 truck.

See all problems of the 1999 Nissan Frontier 🔎.

My complaint is in regards to "mfg bulletin number: ntb01038", which is very specific in identifying the "right hand exhaust manifold cracking". If this technical bulletin is so specific, would that imply that there is a know defect with the manifold, and if so, shouldn't there be a recall for all owners so the defective manifold can be replaced at the manufacture's expense?!?!? if a number of owners have had the same part malfunction to the point where the manufacturer had to publish a "detailed technical bulletin", I would think that this malfunction is much more common and should be addressed as a recall.

Exhaust manafold leak/crack. Took it to a mechanic, he stated cracks exhaust manafolds were common, and he has fixed several. I am concerned that that that exhaust gas may leak into the passenger compartment.

Exhaust manifold has cracked due to manifold is made of one type of metal, and engine block is another type. These two metals heat/cool at different rates causing undue stress on manifold. As a result the manifold has cracked, allowing toxic fumes to enter vehicle passenger compartment.

While driving exhaust manifold/catalytic converter assembly failed. Contacted the dearler. However, the dealer will not cooperate with the consumer.

See all problems of the 1998 Nissan Frontier 🔎.