Structure Problems of Chevrolet Suburban

The contact owns a 2005 Chevrolet Suburban. The contact stated upon taking the vehicle to an independent mechanic for tire replacement, he was informed that the entire chassis was severely corroded. The dealer was notified of the failure and referred the contact to the manufacturer for assistance. The manufacturer was notified of the failure and referred the contact to the NHTSA hotline. The vehicle was not diagnosed or repaired. The failure mileage was approximately 84,000.

See all problems of the 2005 Chevrolet Suburban 🔎.

The contact owns 2015 Chevrolet Suburban. The contact stated that while inspecting the vehicle, the contact saw rust on the frame and saw horizontal lines that became progressively worse over time. A dealer was contacted. The vehicle was taken to the dealer, and the contact was informed that wax could be added to the rust spot and that the repair would be out-of-pocket because the failure was not under warranty. The vehicle was not repaired. The contact related the failure to technical service bulletin: 19-na-255 (wax coating on frame peeling, metal shows corrosion/rusting); however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 114,481.

See all problems of the 2015 Chevrolet Suburban 🔎.

Takata recall. The contact owns a 2007 Chevrolet Suburban. The contact stated that the dashboard on the passenger side began to crack. The contact received notification of NHTSA campaign number: 16v383000 (air bags). The part to do the recall repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

See all problems of the 2007 Chevrolet Suburban 🔎.

Last year 2012, the Suburban was blowing smoke out tailpipe, less than 100k miles, so dealership installed new valve cover with proper grommit for pcv under warranty. Sept. 2013 115k miles, engine bucking, dash lights all on, running on 7 cylinders, chevy dealership states #1 spark plug "came out". And that oil pressure sensor was bad, but still pressure, so not urgent. . . . Nov 19, 2013 - truck now making 'back fire' noises and pressure sensor moving back and forth across 40. . . . Afraid will break down again. Also, have peeling chrome on inside door handles like prior complaint, that is cutting hands/fingers!.

See all problems of the 2008 Chevrolet Suburban 🔎.

The contact owns a 2007 Chevrolet Suburban. The contact stated that the instrument panel cover fractured due to defective material. The instrument panel cover was replaced twice; however, the failure was not corrected. Also, the interior door handles fractured and separated from the door frames. The door handles were replaced. The manufacturer was notified. The VIN was not available. The failure mileage was 75,000.

2011 Chevrolet Suburban 1500. Attorney representing consumer writes in regards to serious structural and safety issues concerning the vehicle. The consumer stated water was leaking inside the vehicle. According to the invoice, the dealer found the water leak coming from the body seam below the dash along the firewall. The passenger and driver front seats made a chattering noise. The dealer greased the tracks. The engine was not running correctly. The dealer replaced the throttle position sensor. Also, the front windshield wipers were inoperative, as well as the rear windshield wiper. The dealer found no power open circuit at the connector and allegedly repaired the wiring to the wiper harness.

See all problems of the 2011 Chevrolet Suburban 🔎.

My back hatch won't open with pod and there are no other ways to get in. I can't open it from the inside or outside, and the window won't open either. This is a safety hazard, and I am finding many other people online are having the same issue as I am.

See all problems of the 2006 Chevrolet Suburban 🔎.

Rear chevy bow tie allows water inside and starts to have interior peeling.

See all problems of the 2010 Chevrolet Suburban 🔎.

I would like to call your attention to an accident that happened to my 17 month old granddaughter. In attempting to steady herself while walking, she accidentally touched the tire on my daughter's Chevrolet Suburban. Her small hand slipped through the hub cap space and came in contact with the hot brake pad, causing her to suffer 2nd degree burns on the palm of her hand. It is my belief that this must have happened to other young children. Parents with whom my daughter and I have spoken had no idea that brake pads were so accessible. I am concerned that the public is not aware of this danger and should become aware as soon as possible. [xxx] information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).

Finger cut from sharp chrome pealing from inside passenger door handle on 2007 chevy Suburban ltz model. Both my wife and son have received deep, painful paper type cuts from this problem. Dealer will not replace for free because out of warranty.

Back glass of the 2004 chevy Suburban disengage from the vehicle. This is very dangerous it could come off while driving and strike another vehicle or worse it could fall on somebody causing serious injuries.

See all problems of the 2004 Chevrolet Suburban 🔎.

The 2001 Suburban's body frame and front wheel wells are poorly designed in that they allow extensive amounts of water spray from flooded roadways to saturate the windshield while driving, causing the drivers view of the road to be completely obstructed creating an unsafe driving environment.

See all problems of the 2001 Chevrolet Suburban 🔎.

Incidents regarding tires and/or frame issues not sure.

Read on RV. Net about hitch failures. Contacted hitch shop, had mine inspected. Upon inspection found that the drift pin holes were elongating and fracturing. Since I tow a travel trailer often, it was determined by the hitch shop that the hitch would eventually fail due to the excessive wear around the drift pin area of the hitch. They stated that the metal may not have been hardened correctly.

See all problems of the 2003 Chevrolet Suburban 🔎.

Running board is loose and not fastened properly on both ends. Dealer and manufacturer were notified. Feel free to provide any further information.

Suburban is unable to pull trailer.

See all problems of the 1996 Chevrolet Suburban 🔎.

Frame has broken on the front of truck. Please provide further detail.