Gasoline Fuel System Problems of Dodge Durango - part 2

When filling the vehicle up with gas, the sensor to stop the gas pump does not work. Result is an overflow of about . 5 gallon of gas to spill on the exterior of the vehical and ground below.

See all problems of the 2006 Dodge Durango 🔎.

While filling up my vehicle with fuel, the vehicle topped off and shut off the fuel nozzel, then fuel came rushing out of the vehicle's filler tube onto the vehicle, my hand and leg, and the ground. This is an ongoing mishap with this vehicle and other 2006 Durango's as indicated by reviewign historical events on this website. It should not take a major mishap or fire to get the appropriate attention this deserves,. Chrysler refises to acknowledge there is an issue, however the 2005 Durango was recalled for the same exact problem.

While filing up with gas, when the pump clicks off when it is full gas spews out of the filler neck while the gas nozzle is still in there. . Apparently this is a widespread problem and a recall has been issued on 2006-2007 models but not 2005's like mine. . It would be nice to be able to fill my truck up with gas and not have it spew out all over the side of my truck and the ground. .

See all problems of the 2005 Dodge Durango 🔎.

When filling with gas, fuel will spill back out of the filling tube, some times when it gets full, other times it will do it all the time. Dodge has had recalls on some of these 2005 for similar issues, but for some reason ours does not fall into the range. Every time will fill fuel there is gas everywhere.

When filling with gas fuel will come back out the filling spout and spill gas all over the car and ground, and sometimes the person filling it. Dodge has had recall on some of the 2005 for the same problem but ours does not fall into their range. This seems to be a big safety concern with fuel going on me, the car, and the ground.

Fuel spill over when refueling on multiple dates and multiple locations of refueling.

When fueling, approx. 1 to 2 quarts of gas burps out of the fuel filler tube. This occurrs regardless of how fast or slow the fuel is dispensed. Seems to not be venting properly. I see daimlerchrysler recall # e01 and h45 have been issued, however my manufacture dates do not fall within range. Can my VIN info be checked and/or are there any other options available to have this repaired by the dealer without cost?.

The contact owns a 2007 Dodge Durango. The contact stated that after refueling the vehicle, gasoline would spew out from the filler neck. The vehicle was not taken to the dealer and the manufacturer was not made aware of the failure. The vehicle was not repaired. The failure mileage was 60,000 and the current mileage was 66,000.

See all problems of the 2007 Dodge Durango 🔎.

Needing more info on just what does the gas cap do. So far I've had my engine light come on, and was told it was because the gas cap wasn't tightened. My latest discovery, I got in my vehicle, turned on the ignition, and the car eventually died, with no further turnover. I got out of the vehicle, thought of checking the gas cap, made a few turns, and got back into my vehicle, and, it turned over without difficulty. What other features does this item have that I should be aware of?.

See all problems of the 2004 Dodge Durango 🔎.

Gasoline sprays out all over ground and vehicle when filling up. After pump automatically shuts off, you can hear the gasoline suck back up and than it sprays out.

While re-fueling the vehicle after the pump auto shut off clicks off about a second or two later fuel comes spewing out under pressure, spilling fuel all over the quarter panel and bumper, and onto the ground, spilling approximately a gallon or so. It appears there are several issues on this from searching online, I just purchased this vehicle used about 3 months ago.

When fueling my Durango, the gass pump will kick off but a short time later gas will spill/spray out of the filler neck. I have tried various gas pumps and pump rates all resulting in the same actions, usually a gas soaked sleeve, gas running down the side of the vehicle, and a puddle on the ground. It is to the point my wife is scared to fuel our Durango. I have called the Dodge dealership and they seem to not know anything about such problems. Chrysler needs to take note of this and do something about it before it results in a serious accident or death.

Each time I refuel my 2006 Dodge Durango limited, gasoline spews back from the fill nozzle onto the vehicle and ground. The last time this occurred, gasoline was splashed on an individual fueling his vehicle on the other side of the pump, ruining his jeans.

The contact owns a 2006 Dodge Durango. The contact stated that while refueling the vehicle, fuel spewed back out from the filler neck. The vehicle was not taken to the dealer for repairs of diagnosis. The manufacturer was made aware of the failure who did not offer any assistance. The vehicle was not repaired. The failure and current mileage was 83,000.

The contact owns a 2007 Dodge Durango 4x4. The contact stated that while driving approximately 65 mph, the vehicle began to shake violently. The contact drove to the side of the road and noticed that the front passenger's side wheel was pointng outward, away from the vehicle. The vehicle was towed to an authorized dealer who stated that the failure was contributed to a loose tie rod. The vehicle was in the process of being repaired. There was a recall possibly related to the failure under NHTSA campaign id number 06v386000 (steering); and the contact planned to notify the dealer to verify whether the VIN was included. In addition, whenever refueling, a substantial amount of fuel would spray out of the filler neck. The manufacturer was made aware of the failures. The approximate failure mileage was 20,000. The VIN was unavailable.

During fill-ups with gas, fuel spills out. There have been multiple recalls on the issue, but the dealer says our VIN is not covered even though it falls within the dates of manufacture that the recall states.

Fuel overflow on fill up. Updated 07/28/bf.

I just purchased a used 2006 Dodge Durango. Everytime I fill it up with gasoline, when it gets full, gasoline overflows from the filler tube and gets on the ground and me. I have read on Dodge forums that this a common problem among Durango owners and I feel is a safety issue.

The contact owns a 2005 Dodge Durango. The contact stated that while refueling, fuel overflowed and was spewed from the filler neck. The dealer was contacted and they stated to the contact that the vehicle was not included in any recalls. The vehicle was neither diagnosed nor repaired. The failure mileage was 90,000 and the current mileage was 120,000.

I have a 2006 Dodge Durango limited with the 5. 7l motor. Every time I fill up with gas it spews out excess gasoline. This happens at any gas station. The vehicle has 72,500 miles on it and this problem has occured for the last 12,000 miles. I have contacted various dealers and I go thru the same routine: VIN reference, then they proceed to tell me it is not covered under lifetime powertrain warranty, and that they have never heard of the issue, and to contact Dodge corporate for assistance. When I contact corporate I follow the steps and they always tell me they cannot assist me at that time. I can never talk to a real person. I have a family and I do not want a fire leading to my families endangerment.

The contact owns a 2008 Dodge Durango. The contact stated that while refueling, fuel was spewed out of the filler neck valve. The vehicle was not taken to the dealer for diagnostics or repairs. The VIN was not available. The approximate failure mileage was 23,000.

See all problems of the 2008 Dodge Durango 🔎.

When we fill up our 2007 Dodge Durango the gas will spray out in large amounts and had sprayed both myself and my wife. It is a major fire and environmental hazard.

2005 Dodge Durango VIN 1d8hb48d45f580001 expels a large quantity of fuel when refueling the vehicle.

Every time I refuel my 2006 Dodge Durango (limited), at least half a gallon of gasoline spews back from the fill nozzle and onto the side of the SUV and ground (and sometimes myself or my wife). This is our family vehicle, and I consider this very dangerous for both my wife and I and our children. This is a hazard that needs to be addressed. I can provide video proof that this is a problem.

I have a 2005 Dodge Durango and after filling with fuel the gas will come pouring back out of the filler spout. I had my mechanic look at it and he cleaned the filter but filled it again today and the same thing happened. I had my VIN checked but is not included in Dodges recall. The Dodge dealer quoted just under $1,000 to fix the problem.

When filling up my 2006 Dodge Durango with gasoline, just after the pump clicks off a large amount of gas will spew out from the filler entrance. This has happened at different gas stations. This started happening about a year ago.

The contact owns a 2006 Dodge Durango. The contact stated that as the vehicle was refueled to maximum capacity, fuel spilled back out from the filler neck abnormally. The vehicle was not taken to the dealer for diagnostics or repairs. The approximate failure mileage was 80,000.

Gas spills out of the fuel filler tube during every refueling. The gas pump does not shut off automatically. As the result, gas is spilled during every time I get gas. This wastes gas, causes an environmental issue, and potentially could cause a fire.

Fuel “spit-back� through the filler neck - issue is well documented with Chrysler as a recall for my make and model, but they misled me into believing they would resolve the issue until after it was diagnosed. My VIN is not listed on the recall list and should be.

Each time I refuel my 2006 Dodge Durango, fuel spills out the filler neck and and onto the ground. I have to warn the pump attendant that fuel will spill out on them if they are standing nearby. If my window is down the vehicle will fill up with gasoline fumes. Our children have complained about the fumes in the back of the vehicle after leaving the gas station. The puddle from the spilled gasoline on the ground is ab out 1. 5 to 2. 5 feet in diameter.

2005 Dodge Durango. When filling at the gas pump, fuel splashes out all over the ground and me when it shuts off. This has been happening since 10k miles, I just put up with it. I found there was a recall, and I want this fixed. Not sure why I did not receive a notice.

I have a 2006 Dodge Durango. The last 5 times I've filled it up, the gas has overflowed even though the auto shut-off clicked on the pump handle. The first time I thought it must be the pump, but now that it's happened 2 more times, I'm am very worried and would like this fixed by Dodge. My vehicle is not on the recall list but is doing the same as the ones that have been recalled.

Everytime I fill up gasoline and after the automatic shutoff in the handle stops the pump, a large amount of gasoline is sprayed onto myself and the vehicle. This is not only a potential fire hazard but a severe environmental issue.

Gasoline splashback on 2005 Dodge Durango, this has happened several times regardless of how the gas is pumped by hand or automatically shut off.

While filling fuel, the pump stopped as normal than shortly after wards a geiser of fuel came spewing out of the Durango's filler nozzle.