Loud Engine Noise Problems of Ford E-350

Tl- the contact owns a 2012 Ford f350 the contact stated that while driving 35 mph, the vehicle began to make an abnormal noise coming from the engine without warning. The failure recurred several times. The vehicle was taken to dealer. The vehicle was diagnosed stated there was bad fuel but the vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 46,000. Bm.

See all problems of the 2012 Ford E-350 🔎.

Tl-the contact owns a 2010 Ford e350. The contact stated that while driving the contact heard an abnormal noise that was coming from the engine. The failure recurred five times. The vehicle was towed to a dealer where it was diagnosed that the spark plug was blown and needed to be replaced. The vehicle was repaired only four times and the fifth time the vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was unknown. Ak.

See all problems of the 2010 Ford E-350 🔎.

My v10 Ford E-350 motor had a head failure and a spark plug blew out while driving. A fire started in the engine compartment and the explosion sound created a panic and startled response that almost lead to a vehicle crash. The vehicle was towed to a repair facility and they were familiar with the problem. They work on fleet vehicles regularly and they stated they have seen this problem many times before. The aluminum head of the engine was too weak to hold on to the spark plug and that lead to the explosion, fire, and damage. The shop informed me that this could very likely happen again because of the defective design of the engine and if I am traveling with my family I could be left stranded, possible a very dangerous part of the highway while driving steep or dangerous roads. If the vehicle catches on fire again it could explode if the gas line ignites. This one cylinder cost $800 to fix but now I have 9 other ones to worry about. I was not able to find a current recall but there will have to be one issued to ensure the safety of any american driving a Ford vehicle with this engine. After researching the internet I have found literally thousands of different people stating similar scenarios.

See all problems of the 1997 Ford E-350 🔎.

The contact owns a 2001 Ford E-350. While driving approximately 30 mph, the contact heard loud sounds coming from the engine. He pulled the vehicle to the side of the road and discovered that the third spark plug blew out of the cylinder head. The vehicle was taken to a mechanic and they re-threaded the cylinder head. The current mileage was 134,701 and failure mileage was 133,345. Updated 09/25/08 updated 09/25/08.

See all problems of the 2001 Ford E-350 🔎.

The contact owns a 2002 Ford e350. While driving approximately 20 mph on normal road conditions, the contact heard a loud noise that sounded like an explosion. The vehicle proceeded to a stop sign and resumed normal operation. The failure occurred without warning. The vehicle was taken to an authorized dealer for inspection and they stated that the spark plug blew out in the engine. The vehicle was repaired. The vehicle was taken to an authorized dealer on a separate occasion for an identical failure. The dealer replaced the spark plugs. The failure mileage was 60,000 and current mileage was 72,000.

See all problems of the 2002 Ford E-350 🔎.

Original owner of 1998 Ford e350 extended-length XLT. At the time of the incident, the car had about 98,000 miles. I was at a stop light, the light turned green and I proceeded through the intersection. I couldn't have been doing more than 15 mph. I heard a loud bang and then the van started to make a loud noise. I put the van in neutral and coasted through the intersection. I had the van towed to butterfield Ford. They told me that the spark plug had blown out of the cylinder, plug coil broke in half, cracked the head. Ford would repair the van but would not offer me a warranty for the work done. So, I had the van towed to a local mechanic who repaired the van (refurbished engine) for $4,500 and they gave me a 100,000 mile warranty on the engine.

See all problems of the 1998 Ford E-350 🔎.