Ford Expedition owners have reported 43 problems related to dash wiring (under the electrical system category). The most recently reported issues are listed below. Also please check out the statistics and reliability analysis of Ford Expedition based on all problems reported for the Expedition.
Intermittent problem of something burning from the dash area; dealer notified and inspected and some repairs was made by replacing heating coil; but condition still reoccurring. Can NHTSA help in this matter.
See
all problems of the 1997 Ford Expedition
🔎.
Windshield wiper light goes on and chimes whenever it feels like it. All parts have been replaced 3 times and the problem still has not been fixed. The dealer know states that they do not have a fix for this yet ; they will contact me when there is a fix. In the meantime, I am driving a car that distracts every day with this sensor light and chiming. The will not allow me to leave my car a fourth time for repair. I think this is due to the CA lemon law. Help!!!!! what are my rights-what can I do?.
See
all problems of the 1999 Ford Expedition
🔎.
While driving 65mph dashboard caught on fire due to a defective electronic control module.
Consumer parked vehicle and went inside the house, and vehicle exploded, catching on fire. Fire department explained to consumer that fire started in the glove compartment.
Generic electronic module system failure caused relay to fail, 4-wheel drive control/transfer case failure. Yh.
Shorts in the electrical system resulted in misfunctioning door locks (repaired), electronic 4wd (still malfunctioning) and failure of internal dome light to turn off. All occurred within the first 12000 miles. 4wd and dome light are still a problem. . Dome light makes vehivcle difficult to drive at night.
Doors, windows, locks all work peridically, the command module was defective. Cj.
See
all problems of the 1998 Ford Expedition
🔎.
Sometimes the system flutters between on and off.