Tank Assembly Problems of Ford F-350

The contact owns a 2005 Ford F-350. The contact stated that the vehicle stalled while driving 20 mph. Upon restart, the vehicle operated as normal. The contact examined the vehicle and stated that the fuel tank was delaminating and clogging the fuel filters. The vehicle was not diagnosed, nor repaired, by the dealer. The failure mileage was 49,500 and the current mileage was 50,200.

See all problems of the 2005 Ford F-350 🔎.

Tl-the contact owns a 2005 Ford F-350 sd diesel. The contact stated that the vehicle was resistant to acceleration attempts. The vehicle was taken to the dealer where the contact was advised that the fuel tank was delaminating and preventing fuel from getting to the engine. As a result, the entire fuel tank would need to be replaced. The vehicle was not repaired. The manufacturer was contacted and they offered no assistance. The failure and the current mileages were approximately 100,000. The VIN was unavailable. Kmj.

I was inquiring about the delamination of Fords fuel tanks on their f-series diesels. I own a 2000 f350 7. 3l deisel. Last week it began to run as if it wasn't getting fuel so I stoped into a local Ford dealer and their diagnoses was the fuel tank on my f350 started to delaminate and clog the entire fuel system. I have owned this truck since it was new and have done all the maintaince and up-keep as required I haven't had any trouble until after the fuel companies started to change the diesel fuel. I have owned the truck since it was new and never had a problem until just recently. The fuel tank problem was diagnosed last week by a Ford dealer in my area and it will cost aproximently $3600 to repair. My question is, "is there giong to be an investigation on this?" I have found a blog from many other customers that are having the same trouble. Someone else should have to pay for this not the consumer or Ford, unless they new this would be a problem and continued to put metal tanks in instead of plastic. I would greatly appreciate a reply.

See all problems of the 2000 Ford F-350 🔎.

The contact owns a 2006 Ford F-350. The contact stated that the vehicle would stall at any time without warning. The dealer diagnosed that the fuel tank was rusted from the inside. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 21,000 and the current mileage was 24,500.

See all problems of the 2006 Ford F-350 🔎.

Liner in the fuel tank corroded and clogged fuel system causing failure of vehicle.

Fuel tank strap has broken again. 2nd time for the rear strap,front replaced 1 time. Also replaced gas tank in 2006 due to leak from rusting at seam,tank is starting to leak again. Tank dropped to the street when strap gave way last time,luckily I was going slow on a side street. Speaking with other owners of these trucks,f-350 superduty 2000 cab and chassis most are having or have had the same issues I am having.

Truck runs rough, check engine light come on, fuel sensor error. There seems to be quite a few similar complaints. Dealers stated fuel tanks are corroding. Why has there not been a recall? this is a manufacturing problem. Ford should deal with it. Or made to.

The contact owns a 2006 Ford F-350. While driving approximately 50 mph, the contact drove over an uneven road surface and the front end of the vehicle began to shake vigorously. The vehicle would also shake abnormally when decelerating. The contact stated that in addition, the check engine warning light was illuminated, the vehicle would erratically shift, and the fuel tank was delaminating. The vehicle was taken to the dealer for diagnostics but the technicians were unable to determine the cause of the shaking. The technicians were able to determine that the transmission shift sensor and the fuel tank would have to be replaced. The vehicle was taken to an independent mechanic where the transmission was rebuilt. And the transmission shift sensor was replaced. The fuel tank was not replaced. The VIN was not available. The approximate failure mileage was 80,000.

The contact owns a 2006 Ford f350. While driving at a speed of 60 mph, the engine stalled without warning. The contact was able to pull over to the shoulder of the road and was able to restart the vehicle within minutes. The dealer advised the fuel tank was defective and would need to be replaced. This was the first incident of the failure. The vehicle was left in possession of the dealer for repairs. The failure mileage was 57,390 and the current mileage was 57,400.

Fuel tank filler tube does not work properly with the gas nozzles here in northern California. Fuel nozzle quits pumping after approximately every gallon of gas that goes in.

See all problems of the 2007 Ford F-350 🔎.

The contact owns a 1997 Ford F-350. The contact stated that while driving 55 mph, the fuel gauge meter suddenly indicated that the fuel tank was empty. The contact also discovered that the panel for the fuel tank was detached, causing the fuel tank to be separated from the chassis. The vehicle was taken to an authorized dealer and the manufacturer was notified. The vehicle was not repaired. The failure mileage was 115,000 and the current mileage was 146,823.

See all problems of the 1997 Ford F-350 🔎.

While driving vehicle and with no warning the gas tank fell out of the vehicle. Dealer notified.

See all problems of the 2002 Ford F-350 🔎.

While traveling with friends and horses, at highway speeds(65) the fuel guage was showing a little over a quarter and the trip computer was still showing about 60 miles to empty. The truck sputtered and engine stalled. It was out of fuel. After trying to get Ford roadside assistance - who said wait 5-6 hrs till morning and we'll get someone out, and aaa who doesn't transport fuel - only gas. The nc hp was contacted and then transported to truck stop and back to truck with fuel - then truck ran fine.

See all problems of the 1999 Ford F-350 🔎.

While driving down on ighhawy heard a constant fuel knocking sound. Contacted dealer. They wetre aware of the problem. No remedy at this time.

Received safety recall regarding fuel tank assembly. Took vehicle in. Called dealer to check on vehicle . Dealer indicated vehicle repairs almost done. Couple hours later, called dealer back and dealer indicated did not have parts. Had to take vehicle back when parts came in.

Fuel tank housing has a hole on the side. Please provide further details.

Dealer refused to repair NHTSA recall 99v311000/manufacturer's recall 99s32 because of a fifth wheel on this vehicle.

Dealer claims cannot perform recall # 99s32 because bracket for fifth wheel interfers with recall.

Consumer not cover under recall due to VIN for the fuel tank vapor recovery valve (99v-311).