Engine Knocking Noise Problems of Ford E-350

The motor home engine operated fine while we were on an extended 1700 mile trip. The gauges registered normal. We checked the oil & antifreeze & they were at the normal levels. After we returned: at mileage 48526 we started the engine on may 6, 2004 the engine started with a large knocking noise & there was white smoke out the tailpipe. 2. Antifreeze had gotten into the oil so the rod bent & #1 cylinder was scored when the engine was started. 3. The head gaskets & head was normal - the whole engine had to be replaced!.

See all problems of the 1997 Ford E-350 🔎.

Engine failure on 2002 e350 Ford van. Van was being operated normally on a rainy day in California. Van stopped running. Driver restarted van and returned to yard. Van engine was making knocking noise. Van was sent to dealer. Dealer determined that vehicle had large volume of water in intake system and said it would not be covered under warranty. Consumer appealed to Ford motor CO. Ford sent field engineer who agreed with findings; adding that the vehicle is designed to ingest a small amount of water, but not that volume of water, therefore it was consumers fault. Consumer says that if that volume of water can enter the vehicles intake system under normal operating conditions then there must be a design flaw or defective part. Nowhere in owners manual does it say not to operate vehicle on rainy days, and the dealer says there is no sign that the vehicle was submerged or driven through deep water. Consumer checked other e350's (earlier model years) in fleet and found evidence of small amounts of water in the intake system leading the consumer to believe that the problem may be a defect with the 2002 model year or a design flaw.

See all problems of the 2002 Ford E-350 🔎.