Power Steering Failed problems of the 2005 Chevrolet Malibu - part 1

Warning message is presented in cars message board stating impending power steering failure. Previous recall for this issue was dated Mar 2014. Car is still showing the same signs as before the recall. Recall issue described below: if power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash. Steering:electric power assist system.

Power steering assist failed on the highway. Was able to pull off and turn the car off and back on and it came back momentarily. Sporadically went on and off for several days, however have had no power steering since Friday October 12th, today is October 16th.

~tl the contact owns a 2005 Chevrolet Malibu. The contact stated that the power steering failed while driving 30 mph. The electric steering warning indicator illuminated prior to the failure. The vehicle was able to be restarted after a few moments. The contact called eagle Chevrolet (1330 old country rd, riverhead, NY 11901, (866) 428-9720), but no failure was found with the vehicle. The previous owner had the vehicle repaired per NHTSA campaign number: 14v153000 (steering) in 2014. The failure mileage was 160,000.

The contact owns a 2005 Chevrolet Malibu. While attempting to turn out of a parking spot, the steering wheel became extremely difficult to turn. The vehicle was taken to jim taylor Chevrolet (139 grimshaw st, rayville, la 71269) where it was diagnosed that the power steering control module failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and transferred the contact to NHTSA. The approximate failure mileage was 161,900.

Power steering started failing. Usually it would come back if I restarted the car. Today it has failed and not returned. Usually seemed to fail when I first started the car, but later it seemed like it failed as I drove the car.

Issue one is the drivers seal welds brake on the rear and front from the floor mount base to the elevated control thus in the case of a crash the seat is compromised to separate completely from the floor mount due to these welds being broke. Second issue fuel pumps begin to leak at the seal of the pump at the fuel tank leaking heavy amounts of fuel from the tank and onto the exhaust. Third issue which I have seen multiple reports of recalls but the dealership denies there is an issue with the maxx that only the base model is effected but while driving the power steering will fail and the car has no control and will violently jerk in one direction throwing the vehicle in to oncoming lanes or even into the ditch. Happens periodically the power steering message appears on main control message screen and car will sound an alarm, other times the entire dash board warning lights from check engine, oil, air bag, seat belt, so on so all come on and the power steering goes out. I have found that this issue usually occurs while accelerating whether slowly or even while trying to speed up more aggressively to merge unto expressway traffic. I have nearly wrecked into numerous cars due to steering going out and wheel will violently jerk one direction or to the other. Not sure why this site shows a recall for power steering but dealership denies there is a active recall for the maxx but they have one for the 2005 base Malibu.

Total power steering failure. Last failed when car pulled into garage, failed days earlier when attempting to leave a parking lot, first failure was while driving down highway, approximately 50 mph (mileage on car at that time is approximated). Problem precisely matches that of NHTSA campaign #14v153000, that is, warning bell chimed, display on radio flashed "power steering," and the steering was no longer power-assisted. I was told by both Chevrolet and gm help centers that my car's VIN did not match those on the recall list, so I guess somebody simply forgot to send my car the memo, as it has failed three times already. Interesting note: the most recent failure occurred after returning home from Chevrolet dealer, where the power steering system/controller (or whatever it's called) was cleared and reprogrammed. Five miles and about twenty minutes later, it failed again.

There was no accident, but this is a complaint against gm for failing to replace all necessary components for a recall. On 3/31/14, gm issued a recall notice, #14v153000 for 1. 3 million cars under 4 separate bulletins & this included my 05 Malibu for steering: electric power assist - there may be a sudden loss of electric power steering assist that could occur at any time (bulletin 14116). Under bulletin 14116, gm would replace only the torque sensor assembly (not the steering motor) for certain gm cars including my car and the gm dealer did so on 10/21/14. Subsequently on 1/10/15, the power steering failed and on 1/14/15, I took this car to the dealer and they stated the steering motor module 6. 605 was defective and replaced it on the same day. I had to pay for this since it was not covered under the bulletin this part seems to be the same part that would be replaced under the other 3 gm bulletins, # 14115, 14117 & 14118 for the same/similar steering problem. My concern is the steering motor module was not initially deemed to be a hazard for gm cars covered under the 14116 bulletin (and my 05 Malibu). Thus, other Malibu owners under the 14116 bulletin may have had the same problem with the motor and another recall may be necessary.

2005 Chevrolet Malibu maxx. Consumer writes in regards to the electric power steering recall notice. The consumer stated he received an invoice stating the recall was completed. However, after leaving the dealer, he experienced a power steering failure. Upon returning to the dealer for an explanation of the power steering failure, the consumer was informed it was a separate problem not related to the repair that was just performed. According to the service ticket, the technician found and checked code c0900 and then checked the alternator. It then stated he found a related TSB that said when finding a code c0900 and b1325 as well as other contributing factors it may need to have a coil replaced and ground strap added. The technician did not state he found both codes.

The contact owns a 2005 Chevrolet Malibu. While driving at an unknown speed, the power steering failed. The vehicle was included in NHTSA campaign number: 14v153000 (steering), but the manufacturer stated that the parts for the repair were unavailable. The vehicle was not taken to the dealer or repaired. The contact had not experienced a failure.

While driving down the highway the power steering failed and I was stuck in everyone's way. Tried to steer to the shoulder but I wasn't strong enough. After the car was turned off for awhile I started it up and the steering came back on just long enough to make it home. Chevy says they don't have part numbers but other privately owned shops in my area say they can get the parts and fix it.

The contact owns a 2005 Chevrolet Malibu. The contact stated that while driving at various speeds, the power steering failed intermittently. The contact stated that the vehicle resumed normal functioned immediately after being restarted. The contact mentioned that he received a notification for recall NHTSA campaign number: 14v153000 (steering) and NHTSA campaign number: 14v252000 (electrical system, electronic stability control, exterior lighting, service brakes, hydraulic, vehicle speed control). The contact stated that the manufacturer had exceeded the reasonable amount of time for the repairs. The dealer stated the parts were not available. The manufacturer was not made aware of the failure. The vehicle was not taken for diagnostic test. The failure mileage was 70,000 and the current mileage was 87,000. Updated 08/27/lj.

This relates to recall campaign 14v153000. In 2009, I first began having power steering failures when accelerating from stopped. I would feel the steering wheel jerk to the path of least resistance (straighten) if I was in a turn, and would hear three chimes (ding-ding-ding). If I released the gas pedal, the power steering would resume operations, but if I maintained pedal activation, power steering would remain off and an alert would illuminate on the dashboard indicating power steering failure. The problem occurred with increased frequency on hot days, especially when air conditioning was operating on high (leading me to believe that it was a loss of power to the steering column, induced by a problem with the way that the electrical system was set up--giving higher priority to a/c fans than to the power steering). In October 2009, the vehicle was repaired under special bulletin 10183. However, in April 2014, I began having this problem again. On every day where the temperature was above 75 degrees, I've had this issue. I called gm and they stated that my VIN is not among those affected, though I drive a 2005 chevy Malibu and I clearly have had the same problem that other vehicles using the same parts. The dealer refuses to look at it unless I have a recall letter. Nhtsa should look into how many customers have been notified out of this my, especially since there is nothing in the language (or logic) of this recall that should exclude my vehicle.

The power steering failed and the vehicle became very difficuilt to steer. The vehicle's computer indicated a power steering problem. After investigating I found out that this is a known problem by general motors.

Making a left turn onto busy road. Steering went out and had to go straight till I could get to a safe spot to stop. Car made chime noise and indicated power steering failure. Had to turn off the car and waited about five minutes. Started car and steering was back to normal.

2005 chevy Malibu mass master brake cylinder was defective and caused the brakes to wear very quickly. Also, the power steering failed. The consumer no longer owns the vehicle, as it was totaled in an accident.

2005 Chevrolet Malibu. Consumer writes in regards to power steering motor failure. The consumer stated while driving, the power steering motor failed, and he lost the ability to steer the vehicle. The vehicle was towed to a repair shop, where the steering motor was replaced at a cost of $ 693. 00.

The contact owns a 2005 Chevrolet Malibu maxx. The contact stated that while driving approximately 10 mph and attempting a turn, the power steering assist failed. The warning light was illuminated and the power steering warning chime sounded. The contact shut off and restarted the vehicle, but the failure was still present. The vehicle was taken to an independent mechanic, who stated that the power steering module would need to be replaced. The manufacturer had previously issued a recall satisfaction campaign for the power steering module but the contact¿s vehicle was not eligible for repairs under the campaign because the cumulative mileage had exceeded 150,000. The manufacturer was notified of the problem. The vehicle was not repaired. The VIN was not available. The approximate failure mileage was 160,000.

While passing on the interstate the power steering failed for several seconds. There was an audible alert then the steering failed. Several other times while turning at low speeds and accerlating the steering fails for only a brief time, but pulls extremely hard in the opposite direction that I am turning.

While making a right turn the power steering failed. . . . . I almost drove head on into oncoming traffic.

The contact owns a 2005 Chevrolet Malibu maxx. The contact stated that while driving 65 mph, the power steering assist failed. The contact continued to drive the vehicle without power steering assist. The following day the power steering operated as designed. The steering failure recurred numerous times intermittently. The vehicle was taken to a dealer for diagnosis and the contact was informed that a sensor in the steering column had become worn unevenly and was sending sporadic signals, causing the failure. The contact was informed that the entire steering column would need to be replaced. The vehicle was not repaired. The VIN was unavailable. The failure and current mileage was 160,000. Updated 04/30/lj the consumer provided a VIN. However, it was a Ford VIN, not a Chevrolet VIN.

Power steering fails when accelerating, especially when attempting to merge onto highway traffic. "power steering failure" flashes on the console and chimes sound. Failure requires car to be steered using bodily force to control the vehicle, and has almost resulted in numerous accidents. Power steering turns back on about 1/2 second after releasing the gas pedal. Does not occur with any relative consistency to warrant taking it to the dealer. I have not been contacted by the manufacturer regarding any relevant recalls for this vehicle.

The contact owns a 2005 Chevrolet Malibu. The contact stated that the power steering assist would fail sporadically. The power steering assist would reset independently once the vehicle was shut off and restarted. The vehicle had not been taken to the dealer for inspection or repairs. The current mileage was 125,007 and the failure mileage was unknown. Updated 05/08/lj.

Was doing 40mph power steering failed spun out hit a wall ended up facing the wrong way on one way highway. . I have had so many issues with the 2005 Malibu it should be pulled off the road for sure, I have had to replace struts 2 times now and about to replace my 2nd fuel pump, my car has stalled out on many occasions, has left me stranded many other occasions. For as much money as I have spent to buy the car used in 2009 with 22000 miles on it it cost us 10500$ we have easily spent over that in repairing it, the worst investment I have ever made. . The lighting constantly burns out the blinkers and headlights fail constantly, the gas cap threads expand and or shrink and causes the cap to either be impossible to remove or impossible to lock depending on the weather. I also have had anti theft security lock out many times where the car stalls and locks me out of using it. Power steering failed, fuel would not pump properly into the vehicle, the fuel gauge displayed improper readings, and the speedometer was inoperative. My remote keys fail constantly as well, alignment which makes the car shake/vibrate at speeds 60+ my cd player does not work either I had dealership repair it before warranty it would lock the disc in the player after warranty problem started again,, my seat warmers get stuck on it was a constant problem even before warranty was done the dealership would fix it but now not under warranty they wouldn't repair it or the cd player again even though it was an obvious complaint before the end of the warranty well we are car shopping now for 2 new cars and I promise you I will never purchase another gm/chevy ever again worst customer service worst cars and to dangerous to reconsider.

The contact owns a 2005 Chevrolet Malibu. The contact stated that the power steering failed, fuel would not pump properly into the vehicle, the fuel gauge displayed improper readings, and the speedometer was inoperative. The local mechanic repaired the fuel system. Neither the dealer, nor the manufacturer were notified of the failure. The failure mileage was 140,000 and the current mileage was unavailable.

The contact owns a 2005 Chevrolet Malibu. The contact stated that while driving approximately 30 mph, the power steering assist failed without warning. The vehicle was taken to a dealer and diagnosed that the power steering module needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the problem. The approximate failure mileage was 97,000. Updated 02/27/lj a recall had been issued for the steering issue. However, the dealer informed the consumer the vehicle had too many miles, to replace under recall. The dealer stated they were only fixing vehicles with under 100,000 miles. Updated 02/27/14.

While accelerating, warning bell dinged and power steering failed momentarily. Has happened a couple of times so far. I plan to call the dealership tomorrow.

The contact owns a 2005 Chevrolet Malibu maxx. While driving approximately 30 mph, there was a loss of power steering and the warning indicator illuminated on the instrument panel. The contact maneuvered to the side of the road, where the vehicle was shut off. After numerous attempts, the contact was able to restart the vehicle. The failure recurred and the power steering failed to regain operation. The vehicle had not been diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 101,000. The VIN was unavailable.

2005 Malibu-power steering system failure.

I was turning onto a road while driving to work and my power steering failed. I almost drove off of the road into a tree! this is the first time this has happened. I have been told that the steering column must be replaced to fix this issue.

The contact owns 2005 Chevrolet Malibu. The contact stated that while attempting to park, the power steering failed without warning. The contact mentioned that after turning the vehicle off and restarting, the power steering was operating as normal. The vehicle was not taken to the dealer. The manufacturer was not made aware of the failure. The vehicle was not repaired. The failure mileage was 60,000 and the current mileage was 81,000.

Steering issues with the car since I bought it, brand new. Took it to a garage twice and was told that these particular cars were having electrical problems with the electronic steering. Today my power steering system failed as I was driving to work. I see numerous complaints about the same issue on the internet but still not recall.

While driving on local street at approximately 35mph, the power steering on our car stopped working making steering very difficult. My husband was driving and he had trouble steering to the side of the road. He turned off the car and restarted it, and the power steering came back on. Within a 2 mile span, this occurred twice. I asked my kids and husband how often this happens, and it's every time the car is driven. If my husband had trouble steering when the power steering stops, it must be even worse for my 2 girls. If this occurs on the highway, there could easily be a serious accident. I looked online and numerous complaints have been made about this problem. There was a service bulletin for it but it needs to be a recall. I read that mazda3 and Mazda 5 cars are being recalled for power steering failure. Why haven't chevy Malibus been recalled? please help.

Clunking noise at low speeds when turning steering wheel- either direction. Power steering failed today - in reverse. Managed to park car in driveway and (per previous complaints I googled) after 20 minutes I went out and started the car & the steering wheel was somewhat normal but I felt a slight catch when I turned wheel either direction. No service has been done on the steering yet by me. I have an extended warranty - covers the power steering pump - but not the shaft.

The contact owns a 2005 Chevrolet Malibu. While driving at speeds of 25 mph, the power steering failed and steering became extremely difficult. The manufacturer advised the warranty had expired and the contact would be liable for any repairs. The current mileage was 85,000 and the failure mileage was 83,000. Updated 10/27/10.